Loading ...
Loading ...
Loading ...
3-44 FUEL SYSTEM (DFI)
Self-Diagnosis
Service Code Reading
The service code(s) is displayed on the LCD by the num-
ber of two digits.
When there are a number of problems, all the service
codes can be stored and the display will begin starting
from the lowest number service code in the numerical or-
der.
Then after completing all codes, the display is repeated
until the ignition switch is turned off or upper button is
pushed for more than two seconds.
For example, if three problems occurred in the order of
56, 16, 33, the service codes are displayed (each two sec-
onds) from the lowest number in the order listed as shown
below. (163356)(163356)· · ·(repeated)
If there is no problem or when the repair has been done,
yellow engine warning indicator (LED) or red warning indi-
cator (LED) and immobilizer warning indicator go off and
service code is not displayed.
ServiceCodeErasing
When repair has been done, yellow engine warning indicator (LED) or red warning indicator (LED)
and immobilizer warning indicator go off and service code is not displayed.
The service codes stored in memory of the ECU can be erased using Kawasaki Diagnostic System
(KDS Ver.3).
Service Code Table
The service codes of the immobilizer system appear to system equipped models.
Service
Code
System Problems
11 FI Main throttle sensor malfunction, wiring open or short
12 FI Intake air pressure sensor #1 malfunction, wiring open or short
13 FI Intake air temperature sensor malfunction, wiring open or short
14 FI Water temperature sensor malfunction, wiring open or short
16 FI Intake air pressure sensor #2 malfunction, wiring open or short
21 FI
Crankshaft sensor malfunction, wiring open or short
24 and 25 FI
Rear wheel rotation sensor signal abnormal (sensor or rotor missing,
too large clearance, rotor tooth worn or missing, wiring open)
First 24 is displayed and then 25
27 FI
Front wheel rotation sensor signal abnormal (sensor or rotor missing,
too large clearance, rotor tooth worn or missing, wiring open) [ABS
Equipped Models]
3
1
F
I
Vehicle-down sensor malfunction, wiring open or short
32 FI Subthrottle sensor malfunction, wiring open or short
33 FI Oxygen sensor inactivation, wiring open or short (Equipped Models)
34 FI
Exhaust butterfly valve actuator sensor malfunction, wiring open or
short
Loading ...
Loading ...
Loading ...