BLDV400NSCSL User Manual

Loading ...

20306741

BLDV7 Series Gas Fireplace

BEFORE YOU START

Read this homeowner manual thoroughly and follow all

instructions carefully. Inspect all contents for shipping

damage and immediately inform your dealer if any damage

is found. Do not install any unit with damaged, incomplete,

or substitute parts. Check your packing list to verify that

all listed parts have been received. You should have the

following:

• Fireplace (Firebox and Burner System)

• Rock Wool

• Log Set

ITEMS REQUIRED FOR INSTALLATION

• Phillips Screwdriver • Framing Materials

• Hammer • Wall Finishing Materials

• Saw and/or saber saw • Level

• Electric Drill and Bits • Tee Joint

• Pliers • Measuring Tape

• Square • Pipe Wrench

• Caulking Material (Noncombustible)

• Fireplace Surround Material (Noncombustible)

• Piping Complying with Local Codes

• Pipe Sealant Approved for use with Propane/LPG

(Resistant to Sulfur Compounds)

FIREBOX FRAMING

Firebox framing can be built before or after the appliance

issetinplace.ConstructreboxframingfollowingFigure 2

foryourspecicinstallationrequirements.RefertoFigure

2forreboxdimensions.Theframingheadersmayrest

onthetopofthereboxstandoffs.Donotbringheaders

below top of standoffs. NOTE: When planning your framing

and installation, keep in mind that your gas line will come

in on the right side of the box (as you are facing it) and

your electricity will come in on the left side.

Thereboxmaybeinstalleddirectlyonacombustibleoor

or raised on a platform of an appropriate height. When

thereboxisinstalleddirectlyoncarpeting,tile,orother

combustiblematerial,otherthanwoodooring,therebox

shall be installed on a metal or wood panel extending the

full width and depth of the enclosure.

PRE-INSTALLATION INFORMATION

NOTE

COLD CLIMATE INSULATION

If you live in a cold climate, seal all cracks around

your appliance, and wherever cold air could enter the

room, with noncombustible material. It is especially

important to insulate the outside chase cavity

betweenthestudsandundertheooronwhichthe

appliancerests,iftheoorisabovegroundlevel.

NOTE: Refer to cold climate pilot information on Page 40

for more information on standing pilot vs. intermittent pilot

options.

WARNING

Donotllspacesaroundreboxwithinsulationorother

materials.Thiscouldcauseare.

Loading ...

User Manual - Page 7