Loading ...
Loading ...
Loading ...
INSTALLATION / USE & CARE
|
21
F
INAL
C
HE
C
K
S
...
c
o
n
t
in
u
e
d
BRASS BURNER FLAME/AIR SHUTTER ADJUSTMENT
The amount of air that enters a burner is controlled by the air
shutter.
Each grill burner is tested and adjusted at the factory prior to
shipment. However, uctuations in gas pressure, gas conversion
and even in the quality of the gas itself may make it necessary to
adjust the burner.
The ames of the main brass burners should be visually
checked.
Flames should be blue and stable with slight yellow tips. The
bright-blue core should be about 3/8 inch high with a total
ame height of about 1 1/2 inches.
The ames should burn quietly (no “torch” sounds) and they
should not “lift” up from the burner.
If your ames do not match those indicated in the photo, ensure
that the air shutter and burner ports are free and clear of dirt,
debris, or spider webs. If clear, then adjust the air shutter.
It is locked in place by a screw which must be loosened before
adjusting. Once adjusted retighten the screw.
To Adjust:
• Remove the racks and briquette trays.
• Lift out the burner, loosen the set screw and then put the
burner back in place and light it.
• If the ame is excessively yellow, indicating insu cient air,
CAREFULLY turn the air shut-
ter counterclockwise to allow
more air to the burner.
• If the ame is noisy (sounds
like a torch) and tends to lift
away from the burner, indi-
cating too much air, turn the air shutter clockwise.
• After the burner cools down, remove it, tighten the air shutter
set screw and reinstall the burner, briquette trays and grill
racks.
NOTE: The ProSear™ does not have an air shutter.
• The appearance of the ProSear™ burner should be visually
checked. The ceramic tiles should be uniformly red to orange
in appearance. There should be no lifting, uttering or lazy
blue ames. Some food particles will show as yellow ames
but should burn o .
ONE LAST THING
Finally, before leaving, check all the burners for proper opera-
tion. Make sure the control knobs turn freely and completely
through their full range.
IMPORTANT:
Make sure the owner knows where the main gas supply shut
o valve is located.
Finally, for safety and for proper use & care, you must leave
this manual with the owner. Make sure you advise them to
keep it for future reference.
For technical assistance call:
Preferred Customer Service
888-845-4641
,
indicating
insu
cient
air,
shutter clockwise.
BE EXTREMELY CAREFUL AROUND HOT BURNERS
AND OTHER GRILL PARTS.
DANGER!
Loading ...
Loading ...
Loading ...