Loading ...
Loading ...
Loading ...
FOG THE ENGINE
1. Treat the fuel system with POLARIS Carbon Clean or other equivalent fuel
treatment. Follow the instructions on the container. Start the engine. Allow it
to idle for several minutes so the Carbon Clean reaches the injectors. Stop
the engine.
2. Remove the spark plugs and add 1–1.5 oz. (29.5–44 cc.) of engine oil. To
access the plug holes, use a section of clear 6 mm (1/4”) hose and a small
plastic squeeze bottle filled with the pre-measured amount of oil. Do this
carefully! If you miss the plug holes, oil will drain from the spark plug cavities
into the hole at the front of the cylinder head, and appear to be an oil leak.
3. Reinstall the spark plugs. Torque to specification.
4. Apply dielectric grease to the inside of each spark plug cap. Do not reinstall
the cap onto the plug at this step.
5. Turn the engine over several times. Oil will be forced in and around the
piston rings and ring lands, coating the cylinder with a protective film of fresh
oil.
6. Reinstall the spark plug caps.
7. If POLARIS fuel system additive is not used, fuel tank, fuel lines, and
injectors should be completely drained of gasoline.
INSPECT AND LUBRICATE
Inspect all cables and lubricate all areas of the vehicle as recommended in the
Periodic Maintenance Chart.
BATTERY MAINTENANCE
Remove the battery and recharge it as outlined in the Battery Charging section.
Store the battery in a cool, dry place.
STORAGE AREA / COVERS
Set the tire pressure and safely support the vehicle with the tires slightly off the
ground. Be sure the storage area is well ventilated. Cover the vehicle with a
genuine POLARIS cover. Do not use plastic or coated materials. They do not
allow enough ventilation to prevent condensation, and may promote corrosion
and oxidation.
ACCESSORIES
Auxiliary power outlets provide 12-volt power for operating accessories.
Accessory outlets are available for all models. POLARIS also has a wide range
of additional accessories available for your ATV. Always install accessories that
are approved for ATV use. Your dealer can assist.
158
MAINTENANCE
Loading ...
Loading ...
Loading ...