Loading ...
Loading ...
Loading ...
PROBLEM
WHI not start
Hard to start
Engine will not turn over
Engine clicks but will not
start
Loss of power
Excessive vibration
TROU LESHOOTI
CAUSE
1. Out of rue!.
2. Engine not "CHOKED" properly.
3. Engine flooded.
4. Bad spark plug.
5. Dirty air filter.
6, Dirty fuel filter.
7, Water in fuel.
8. Loose or damaged wiring.
9. Carburetor out of adjustment.
!0. Engine valves out of adjustment.
t. Dirty air fliter.
2. Bad spark plug.
3o Weak or dead battery.
4, Dirty fue_filter.
5. Stale or dirty fuel
6. Loose or damaged wiring.
7. Carburetor out of adjustment.
8. Engine valves out of adjustment.
1. Clutch/brake pedal not depressed.
2. Attachment clutch is engaged.
3. Spark plug wire is disconnected;
4. Weak or dead battery.
5. Blown fuse.
6. Corroded battery terminals.
7. Loose or damaged wiring.
8. Faulty ignition switch.
9. Faulty solenoid or starter.
10. Faulty operator presence switch(es).
1. Weak or dead battery.
2, Corroded battery terminals.
3. Loose or damaged wiring.
4. Faulty solenoid or starter.
1. Cutting too much grass.ffoo fast.
2, Throttle in "CHOKE" position.
3. Build-up of grass. _eaves and trash under mower.
4. Dirty air filter.
5. Low oil level/dirty oil.
6. Faulty spark plug.
7, Dirty fuel filter,
8. State or di_y fuel.
9. Water in fuel.
10. Spark plug wire loose.
11. Dirty engine air screen/fins.
!2. Dirty/clogged muffler.
18. Loose or damaged wiring.
14. Carburetor out of adjustment.
15. Engine valves out of adjustment.
1. Worn, bent or loose blade.
2. Bent blade mandrel,
3. Loose/damagedpart(s),
G POINTS
CORRECTION
1. Fillfueltank.
2. See TO START ENGINE' in operation section.
3. Wait several minutes before attempting to start.
4. Replace spark p{ug.
5. Clean/replace air filter.
6. Replace fuelfliter.
7. Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel filter.
8. Check aft wiring.
g. Contact Sears Service Department.
10. Contact Sears Service Department.
1. Clean/replace air filter.
2, Replace spark plug.
8. Rechargeor replace batter€.
4. Replace fuel filter.
5. Drain fuel tank and refill with fresh gasoline.
6. Check all wiring.
7. Contact Sears Service Department.
8. Contact Sears Service Department.
t. Depress Clutch/brake pedal.
2. Disengage attachment c_utch.
3. Connect wire to spark plug,
4, Recharge or replace battery,
5, Replace fuse.
6, Clean battery terminals.
7. Check all wiring.
8. Check/replace ignition switch.
9. Check/replace solenoid or starter.
!0. Contact Sears Service Department.
1. Recharge or replace battery.
2. Clean battery terminals.
3. Check all wiring.
4, Check/replace solenoid or starter,
1. Set in "Higher Cut" position/reduce speed.
2. Adjust throttle control.
& Clean underside of mower housing.
4. Clean/replace air filter.
5. Check oil level/change oil.
6. C]ean and regap or change spark plug.
7. Replace fuel filter.
8. Drain fuel tank and refill with fresh gasoline.
9. Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel filter.
t0. Connect and tighten spark plug wire.
tl. Clean engine air screen/fins.
12. Cleanlreplace muffler.
13. Check all wiring.
14. Contact Sears Service Department.
l& Contact Authorized Service Facility.
I. Replace blade. Tighten blade bolt.
:2, Replace blade mandrel
3. Tighten loose part(s). Replace damaged parts.
26
Loading ...
Loading ...
Loading ...