Loading ...
Loading ...
Loading ...
TROUBLESHOOTING POINTS
PROBLEM CORRECTION
=
Engine continues to run
when operator reaves seat
with attachment clutch
engaged
Poor oat _uneven
u,,,,,, , ,, i i,
Mower blades wttt not
rotate
Poor grass discharge
Headlight(s) not working
(!f so equipped)
i
Battery wgt nut charge
Loss of drive
,,i
Engine "backfires _"
when turning engfne
"OFF"
=, , _.
rCAUSE
1 Faulty operator-safety presence cohtral syslera
1 Worn, bentOrtease blade
2 Maw_ rdeck net teve[
3 Buildup of grass,leaves, and frash under rnews_.
4 Benl btads mandrel
B Oiogg_d mower deck vent holes from buildup o!
grass, ]eaves, and trasharound mandrels
1 Obsln_ctloninclutchmechanism
2, Worn/damaged mower drivs beg
3 Frozen idler pufley
,_ Frozen blade mandrel
1. Engine speed leo slow.
2 Ttavsf speed too fast
3, Wet grasa_
4, Mowa_deck not level
5 Lnwluneven lira air pressure
g Worn, bsntOr loose blade
7 Buildup Ofgrass, leaves and trashunder mower
g Mower drive heft worn
g Blades Impropady tnstafted
10 tmpmperblades used.
11 Clogged mower deckvent holes from buildup of
grass, _eaves,and trash around rnandrets
! Switch ts "OFF"
2 Bu}b(a) burned out
3 Faugy light swltch
4 Loose or damaged wiring_
5 g_ov_nruse
k
I Bad batterye@ll(a)
Poor esbtoecnnecllons
3 FBUityregulator(ifss equipped)
4r really s11ernator
1 Freewheel controlin=disengaged" position
2, Motion ddve bell worn, damaged, or broken
3. Nr trapped tn transmissionduring shtpment
ors_r_lcing
1 Check Wiring,swl_eheeand connecgons .Ifnot
corrastod,contact an aulhodze d servleecenter/
depaffment
1 Replace blade..'Tight_n blade bait
2 Level mower deck.
3 C_eanunderside o! mower houalng:
4 Replace blade mandrel
5 Clean around mandrels fo open vent hates
1 Remove obstruction
2 Replace mower ddve bell
3 Replace ]dlerpulley
4. asp|ace blade rnandret
• .ill
1 Race throttle controltn "FAST" pastgon
2 Shift to slower speed.
3 AgOwgrass todry before mpwing.
4 Level mower deck
5 Checkt_res for properair pressure
B Bsptaceteharpen blade T_ghtsnbrads bolt
7. Cleanundemide atmows Fhousing
B: Replace mower drivebelt.
g Reinstallblades sharp adgs down
1O, Replace with blades gated In IhIe manual
ll Clean around mandrels foopen vent hates
1. Turn s'Mlch"ON"
2 Replace bulbis)
3. Cheek/reptabs light switch
4 Cheekwlring and connec_0ne
5; Replace fuse
i ' Jl,=,
1 Replace battery,
2 Check!cteafl allconni_ctlons
3 Replace regulatsr
4 Replace alternator
=
1 Place frsewhaat controltn "engaged" position
2 Rapists motion d_ive bell
3 Purge transmission
1 Engine throlttB conlrol net set at "SLOW" "[ Move throltle'contrel to 'SLOW" position and allow
positionfor 30 seconds before stoppingengine to Idle for 30 seconds before stopp!ng engine "
30
Loading ...
Loading ...
Loading ...