Sealey CTI130 Rechargeable Tyre Inflator & Power Bank User Manual

RECHARGEABLE TYRE INFLATOR & POWER

BANK WITH WORKLIGHT

MODEL NO: CTI130

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these

instructions, and properly maintained, give you years of trouble free performance.

IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE

THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR

PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.

1. SAFETY

 WARNING! Read operation instructions before use.

8 DO NOT leave the unit unattended while in operation.

9  Checkcapacityandmaximuminationpressureofinatablebeforecommencingination.

9  Monitorthepressuregaugewhileinoperation.

9  Thegaugeshouldbeusedasanindicationofpressureonly.Werecommendtheuseofadialpressuregaugefordenitivereading.

 WARNING!Thiscompressoriscapableofproducingahighpressure.

8 DO NOTinateanyitembeyonditsmaximumcapacity.

8 DO NOTdirectinationhoseconnectorheadatyourself,othersoranimals.

8 DO NOTcarrybythehose,oryankthehosefromaninationvalve.

8 DO NOT pull the power cable from the vehicle accessory socket by the power lead.

8 DO NOTgetthecompressorwetoruseintherain.

8 DO NOTusethecompressorforataskitwasnotdesignedtoperform.

8 DO NOToperatethecompressorifanypartsaremissingasthismaycausefailureorpossiblepersonalinjury.

9  Keepchildrenandnonessentialpersonsawayfromtheinationarea.

9  Keepthecompressorcleanandingoodcondition.

9  Avoidbendingthehoseduringination.

9  Turno󰀨thepumpimmediatelyifoverheatingoranyabnormalityisobservedduringoperation.

9  Ifnopresetpressurevalue,DO NOTleavethepumpunattendedduringinationtopreventtheairpressuregettingtoohigh.

9  Keepthepumpawayfromanyammableorcombustibleobjectsduringoperation,sincethebuilt-inDCmotormaygeneratesparks

 duringoperation.DO NOTthrowtheproductintoreorhouseholdwaste.

9  Keepthepumpawayfrommoisture,sandandshock.

8 DO NOTstorethepumpinextremelycoldorhotplaces.Thatwillshortenproductlife,damagebattery,ordeformthestructural.

9  Avoidusingstrongchemicalsordetergentstocleantheproduct.

8 DO NOT disassemble the product.

8 DO NOT let children use the product.

8 DO NOTinsertthehoseintomouth,ears,oreyesofhumansoranimals.Itmustnotbeusedasatoy.

9  Thiscompressorisnotdesignedforcontinuoususe.Operationoveranextendedperiodoftimewilloverheattheunitanddamage

 thecompressor.Itshouldnotbeusedcontinuouslyformorethan20minutes.After20minutes,turnito󰀨andletitcoolfor15 

 minutesbeforeresumingoperation.

2. INTRODUCTION

 Rechargeableunitforportabilityandquickinationanywhere.PowerbankwithUSBoutput5V1Aidealforchargingmobilephones

 andportabledevices.Suitableforinatingtyresoncars,vans,4x4s,motorcyclesandbicycles.Maximumpressure120psi.Pressure

 unitspsi,kPa,kg/cm²andbar.Autostopfeature.Airow0.68CFM19L/MINwithaninationtime0-30psiin342sec(175/70/R13).

 BacklitLCDdigitaldisplay.1WSMDLEDworklightwithstrobeandSOSlight.Theaccessorykitincludesa150mmextensiontube

 withSchraderconnection,Prestatypeadaptor,ballspike,inatablesadaptorandaUSBchargingcable.

3. SPECIFICATION

CTI130Issue314/10/24

Original Language Version

©JackSealeyLimited

Refer to

instructions

Model No: CTI130

Airow: 0.68CFM19L/MIN

Battery: 2000mAh x2

BatteryChargeTime: 3hours

Battery Run Time: 20 Minutes

HoseLength: 150mm

InationTime: 0-30psiin342sec(175/70/R13)

MaximumAirSupply: 120psi

Maximum Current: 6A

NettWeight: 0.50kg

PressureUnits: PSI,kPa,kg/cm²andbar

4. FEATURES / CONTENTS

5. OPERATION

PRESSURE PRE-SET

PressandholdtheMbuttontochangethepressureunit,Press:+or-increaseordecreasethetargetpressure(numberswillash).When

youreachthedisiredpressurepushtheMbuttonandthenumberswillstopashing.PressMbuttontostartination,whendesiredpressureis

reached the machine will stop automatically.

BATTERY DISPLAY

Digitaldisplayscreenhasthreebatterymodes.

Firstbatterydisplay:Between70%and100%.

Secondbatterydisplay:Between40%and70%.

Thirdbatterydisplay:Between10%and40%

Original Language Version

©JackSealeyLimited

CTI130Issue314/10/24

1 Air hose

2 Heat resistant hose

3 Pressure display

4 Operation button

5 LEDlight

6 USBchargingpoint

7 Type-Cchargingpoint

1.Connectairhosetotheinator. 2.Screwtheairhosetothevalve. 3.Pressandholdfor3secondstoturn

on the power.

4.Press3secondstoreawakenscreen. 5.PressMbuttontochangethefour

di󰀨erentmodes.

6.LongpressMbuttontochangethethe

pressure unit.

7.Pressthe+or-toincreaseor

decreasethetargetpressure.

8.Shortpresstostartinating. 9.Whenpressurereachestarget,theunit

willstopautomatically.Tostopinationat

anytimepress.Switcho󰀨powerafter

use.

6. TROUBLESHOOTING

Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR

01284 757500 sales@sealey.co.uk www.sealey.co.uk

ENVIRONMENT PROTECTION

Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento

arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely

unserviceableandrequiresdisposal,drainanyfluids(ifapplicable)intoapprovedcontainersanddisposeoftheproductandfluids

accordingtolocalregulations.

WEEE REGULATIONS

DisposeofthisproductattheendofitsworkinglifeincompliancewiththeEUDirectiveonWasteElectricalandElectronicEquipment

(WEEE).Whentheproductisnolongerrequired,itmustbedisposedofinanenvironmentallyprotectiveway.Contactyourlocalsolid

wasteauthorityforrecyclinginformation.

Note:Itisourpolicytocontinuallyimproveproductsandassuchwereservetherighttoalterdata,specificationsandcomponentpartswithoutprior

notice.

Important: No Liability is accepted for incorrect use of this product.

Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.

Original Language Version

CTI130Issue314/10/24

Problem Cause Solution

Slowination. Low battery.

Airleakage.

Fullychargeandtryagain.

Checkforleakagefrompipework.

Inationfailure. Low battery.

Pressurevaluehigherthanpreset.

Fullyrechargeandtryagain.

Setinatortoapplicablemode.

Unchangeablepresetpressure

value.

Value set has reached limit for

mode set.

Changemodeandretry.

Pressure valve reads “zero”. Pressurevalueoftheballoons,toy

ballsetc,couldbelowerthan

dectablerange.

Batterylevelindicatornotlighting

upwhencharging.

Improper adaptor or cable. Replaceadaptorandrecharge

withoriginalchargingcable.

Sealey CTI130 Rechargeable Tyre Inflator & Power Bank

Product's Documents

Instructions

Specifications

Sealey CTI130 Questions and Answers