F54RW User Manual

Loading ...

24 Euromaid 540mm Upright Cooker INSTALLING THE GAS COOKER

Gas connection

A Inletpipejoint

B Gasket

C Stableunion

Procedure

Maketheconnectiontothegassystemusingarigid

metalpipeandregulationunions,orwithastainless

steelhosecomplyingwiththelocalstandard.Ifmetal

hosesareused,takecarethattheydonotcomeinto

contactwithmobilepartsandarenotcrushed.

Whenmakingtheconnection,takecarenottoapply

stressesofanykindtotheappliance.

Readthesepointsbeforeconnectingtothegassupply;

• Thegasconnectionpointisa1/2”BSPexternal

threadlocatedattherearoftheapplianceasshown

intheRearView.

• Aregulatorissuppliedfornaturalgasappliances

whichmustbettedinthesupplylinetothe

appliance.ForLPGthesuppliedbrassTestPoint

Adapter/Fittingmustbettedtothesupplyline.

• Itisrecommendedtottheregulatorortestpoint

ttingtotheapplianceconnectionpoint,thent

eitherhardpipingoraexibleconnectionfrom

theregulatorortestpointttingtoconsumerhard

piping.Ensureinstallationallowswithdrawalof

appliance.ForexiblehoseinstallationAS/NZS

5601.1clauses5.9and6.10.1.9mustbefollowed.

Unpacking

Donotttheburnercrowns,burnercapsandtrivets

untilafterthecookerhasbeeninstalled.

Checking gas pressures

Beforeinstallationcheckthatthecookerissuitablefor

thegassupply.Todothischeckthegastypeonthe

cartonstickeroronthedataplatebehindthebottomof

theovendoor.Ifthecookerisrequiredtobeusedwith

LPG,thesuppliedconversionkitmustbeused.

Thefollowingshowsthesupplyandoperating

pressuresforvariousgassupplies.

Operatepressureatappliancetestpoint:

1.00KPa(Naturalgas);N2.75KPa(UniversalLPGgas)

Thefollowingtableshowstheinjectorsizesforeach

burner.

Injector Natural gas Universal LPG

Auxiliaryburner 0.93mm 0.57mm

Semi-rapidBurner 1.16mm 0.71mm

TripleringBurner 1.75mm 1.10mm

Connection to the gas supply

■

ThegasConnectionmustbemadeinaccordance

withthelocalstandards.

 Wheninstalling,tasafetytapattheendofthe

pipeline.Theapplianceleavesthefactorytested

andsetforthetypeofgasindicatedonthe

plateinsidethebottomguard,closetothegas

connectionpipe.Makesurethatthetypeofgasto

besuppliedtotheapplianceisthesameasthat

shownontheplate.

■

Formaximumefciencyandminimumconsumption,

makesurethatthegassupplypressurecomplies

withthevaluesshowninthegasusedisdifferent

fromthatspecied(orvariable).asuitablepressure

regulatormustbeinstalledonthesupplypipeline.

Installing the gas cooker

Loading ...

User Manual - Page 24