Sealey MAC10S Tyre Inflator & Emergency Puncture Sealant User Manual

12V Tyre InflaTor + emergency

PuncTure SealanT KIT

Model no: mac10S

Thank you for purchasing a Sealey product. manufactured to a high standard, this product will, if used according to these

instructions, and properly maintained, give you years of trouble free performance.

IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE

THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR

PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.

1. SafeTy

9  Stopsomewheresafelyawayfromothertrafc.Trytoavoidcausinganobstructiontoothers.

9  Makesureyourhandbrakeisonandthecarignitionisoff.

9  Turnonthevehicleshazardlights.

9  Ensureyouarevisibletootherroaduserswhilstusingtheequipment.

9  Ifavailable,wearahigh-visvestandsetupawarningtriangle.

9 Keep the compressorcleanandingoodcondition.

9  Replaceorrepairdamagedparts. Use recommended parts only. Unauthorised parts may be dangerous and will invalidate the

warranty.

9  Keepchildrenandnon-essentialpersonsawayfromtheworkarea.

 WarnIng! Thiscompressoriscapableofproducingahighpressure.Do noTinflateanyitembeyondit’smaximumspecified 

 pressure.

9  The12voltaccessoryplugmustnotbereplacedwithanyothertypeofplugorelectricalsupply.

8 Do noTusenearflammablesolids,liquidsorgases.

8 Do noTdirectinflationhoseconnectorheadatyourself,othersoranimals.

8 Do noTleavethecompressoroperatingunattended.Alwaysmonitoritandtheinflationpressure.

8 Do noTcarrybythehose,oryankthehosefromaninflationvalve.

8 Do noTpulltheplugfromtheaccessorysocketusingthelead.

8 Do noTgetthecompressorwetoruseintherain.

8 Do noTusethecompressorforataskthatitisnotdesignedfor.

8 Do noToperatethecompressorwhenyouaretiredorundertheinfluenceofalcohol,drugsorintoxicatingmedication.

8 Do noT operatethecompressorifanypartsaremissingorthecompressorisdamaged,asthismaycausefailureand/orpersonal

 injury.

8 Do noTopentheunit.

2. InTroDucTIon

emergencykitincludes12Vcompressor,450mlsealantbottle,accessoriesforinatables,instructionsandzippedstoragebagtted

withhookandloopfasteningforsmartstorage.CansealapunctureuptoØ6mmattheroadsideinunder10minutes.Sealant

ismanufacturedfromnaturalrubber,meaningtyrecanbewashedoutatthepointofaprofessionalrepair.Verysimple-to-usekit

requiresnotools,noneedtoremovethevalvecoreandisTPMSsafe.Plugsintoa12Vvehicleaccessorysocket.Replacement

sealantbottleavailable,SealeyModelNo.MAC10SR.Suitableforcars,vansand4x4s.

3. SPecIfIcaTIon

model no.: ...............................................................mac10S

hoselength(Compressor)........................................ 600mm

hoselength(Sealantbottle)...................................... 500mm

operatingvoltage.............................................................12V

Maximumcurrent.............................................................10A

Powercordlength............................................................. 3m

Maximumpressure..................................................... 100psi

Typicalinationtime..... 195/55/R15-0-35psiin270seconds

450mlReplacementTyreSealant+Hose............. MAC10SR

MAC10SIssue131/10/19

Original Language Version

©JackSealeyLimited

Refer to

instructions

Hotsurfaces

Donotcover

Keepindryarea

protectfromrain

4. conTenTS

5. oPeraTIon

5.1. general noTeS

 WarnIng!Ensureyouhavereadandunderstoodthesafetyinstructions.

5.1.1. Checkthetyreforphysicalsignsofdamage.

noTe:Iftheholeortearisgreaterthan6mmitisprobablytoobigtox.Considerseekingassistance.

8 Do noTpulloutanyobjectsstuckinthetyre,thismightmaketherepairhardertoachieve.

noTe:Ifpossible,workonthetyrewiththehole/tearneartothelowermostpointofthetyre.Thesealantwillworkbetterthatway.

noTe: Wheninating/repairingatotallyattyrestillttedonavehicle,thereshouldnotbeanyweightonit.Thevehiclemust, 

 therefore,bejackeduptotaketheweightoffthetyre.Reviewjacksafetyinstructionsandvehiclemanufacturer’sguidelinesfor 

 jacking.

5.1.2. Positioncompressoronarm,atsurfaceandlocatedsothattheairhosereachesthetyrevalve.

ImPorTanT:Inationwillonlybeeffectiveiftheconnectorsarefullytted.

 WarnIng!Thecompressormustbeswitchedofffortwentyminutesaftereachtwentyminuteperiodofcontinuousoperationto 

 preventexcessiveheatbuild-up.

5.2. PuncTure rePaIr

noTe:ReviewSection5.1beforebeginningthisprocess.

5.2.1. Unpacktheunitandcheckthatallitemsarepresentandingoodworkingcondition.

5.2.2. CheckthatthecompressorOn/OffswitchisintheOFFpositionandplugthe12Vplugintothevehicle’saccessorysocket.

5.2.3. Gentlyshakethesealantbottletomixitthoroughly.

ImPorTanT:Repairwillonlybeeffectiveiftheconnectorsarecorrectlytted.

5.2.4. Connectairhose(g.1.6)tosealantairinletconnector(g.1.1)

5.2.5. Invertsealantbottleandlocateintofaceofcompressor(g.1.2).Rotateclockwisetolockinplace.

5.2.6. Connectsealantoutlet(g.1.7)totyrevalve.

5.2.7. Turnthecompressorontobegintheprocess.Oncethetyrereachestherequiredpressureturnthecompressoroff.

noTe:Ifthetyrehasnotinatedafterapproximately10minutescheckallconnectionsforleakage/blockage.Ifnoneisevident

 considerseekingassistance.

noTe: Ifthetyreisaccidentallyover-inated,usethereliefvalveonairhose(g.1.6)toallowairoutofthetyre.

 WarnIng!Afterrepairingthetyre,theairhoseanditsconnectorsmaybehot.Leavetocoolfor2to3minutesbeforeremoving.

5.2.8. Removeallttingsandthepowersupply.Stowtheitemsincarrycaseandplaceusedsealantbottleinaleak-proofbagifavailable.

5.2.9. Driveforabout2miles(~3km)sothatsealantcansealthedamagedarea.Stopandchecktyrepressure,topuptyrepressureif 

 required.

8 Do noTdrivefasterthan50mph(80kph)ontherepairedtyre.

8 Do noTdrivefurtherthan125miles(200km)ontherepairedtyre.

8 Do noTcontinuedrivingifanyvibrations,unsteadysteeringornoisesoccur.Considerseekingassistance.

5.3. Tyre / InflaTaBleS InflaTIon

noTe:ReviewSection4.1beforebeginningthisprocess.

5.3.1. CheckthatthecompressorOn/OffswitchisintheOFFpositionandplugthe12Vplugintothevehicle’saccessorysocket.

5.3.2. Removethevalvedustcapandscrewtheconnectorontothevalvestem.

ImPorTanT:Inationwillonlybeeffectiveiftheconnectorisfullyttedontothevalve.

5.3.3. PressthecompressorOn/OffswitchtotheONpositionandthecompressorwillbegintooperate.

5.3.4. InatethetyretothedesiredpressureandturnoffthecompressorbypressingtheswitchtotheOFFposition.

noTe: Thegaugemaybesubjecttouctuationwhilstpumping.

5.3.5. Removetheairhosefromthetyrevalvebyunscrewingconnectorfromthetyrevalve,takingcaretominimiseairlossinthe 

 process.Replacethedustcap.

5.3.6. Disconnectthe12Vplugfromthevehicle’saccessorysocket.

noTe:Thepressuregaugeisnotacalibratedinstrument.Itisrecommendedtouseacalibratedtyrepressuregaugeforan 

 accuratenalreading.

noTe:Thecompressormayalsobeusedonitemssuchasinatabledinghies,sportsballs,airbedsetc.usingoneofthetwo 

 adaptorssupplied.

noTe: Ifthetyre/inatableisaccidentallyover-inated,usethereliefvalveonairhose(g.1.6)toallowairout.

cauTIon: Someitemsmaynotindicatethepressurerequiredorthesafemaximumpressure.Beverycarefulnottoover-inate.

6. maInTenance

6.1.  Beforeeachusecheckallhosesandttingsaresoundandserviceable.

6.2.  Wipedownunitwithdampclothanddrythoroughlyifsoiled.Do noTgettheunitwet.

6.3.  Replaceallhosesbackintorelativecompartmentsincompressorbodyandplace

MAC10SIssue131/10/19

Original Language Version

item

no.

description item

no.

description

1 Connector-airinlet 5 Powercable

2 Sealantlocation 6 Airhose+deationvalve

3 on/Offswitch

Tyrevalve

Connector

4 Pressuregauge

g.1

Sealey group, Kempson Way, Suffolk Business Park, Bury St edmunds, Suffolk. IP32 7ar

01284 757500 01284 703534 sales@sealey.co.uk www.sealey.co.uk

enVIronmenT ProTecTIon

Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento

arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely

unserviceableandrequiresdisposal,drainanyfluids(ifapplicable)intoapprovedcontainersanddisposeoftheproductandfluids

accordingtolocalregulations.

Weee regulaTIonS

DisposeofthisproductattheendofitsworkinglifeincompliancewiththeEUDirectiveonWasteElectricalandElectronicEquipment

(WEEE).Whentheproductisnolongerrequired,itmustbedisposedofinanenvironmentallyprotectiveway.Contactyourlocalsolid

wasteauthorityforrecyclinginformation.

note:Itisourpolicytocontinuallyimproveproductsandassuchwereservetherighttoalterdata,specificationsandcomponentpartswithoutprior

notice.

Important:NoLiabilityisacceptedforincorrectuseofthisproduct.

Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.

MAC10SIssue131/10/19

Original Language Version

Sealey MAC10S Tyre Inflator & Emergency Puncture Sealant Kit 12V

Product's Documents

User Manual

Specifications

Sealey MAC10S Questions and Answers