Loading ...
Loading ...
Important Safe Operation Practices
2
3
WARNING!
This symbol points out important safety
instructions which, if not followed, could endanger
the personal safety and/or property of yourself
and others. Read and follow all instructions
in this manual before attempting to operate
the equipment. Failure to comply with these
instructions may result in personal injury. When
you see this symbol. HEED ITS WARNING!
WARNING!
CALIFORNIA PROPOSITION 65
Engine Exhaust, some of its constituents, and
certain vehicle components contain or emit
chemicals known to State of California to cause
cancer and birth defects or other reproductive
harm.
DANGER!
This engine was built to be operated according to
the safe operation practices in this manual. As with
any type of power equipment, carelessness or error
on the part of the operator can result in serious
injury. Failure to observe the following safety
instructions could result in serious injury or death.
Training
1. Read, understand and follow all
instructions on the engine and in the
manual(s) before attempting to assemble
and operate. Keep this manual in a safe
place for future and regular reference and
for ordering replacement parts.
2. Be familiar with all controls and their
proper operation. Know how to stop the
engine and disengage them quickly.
3. Never allow children under 14 years of
age to operate the engine. Children 14
and over should read and understand the
instructions and safe operation practices
in this manual and be trained and
supervised by an adult.
4. Never allow adults to operate the machine
without proper instruction.
5. Keep the area of operation clear of all
persons, particularly small children and
pets. Stop machine if anyone enters the
area.
Preparation
1. Wear sturdy, rough-soled work shoes and
close fitting slacks and shirts. Loose fitting
clothes or jewelry can be caught in the
moving parts. Never operate the machine
in bare feet or sandals.
2. Disengage clutch levers and shift (if
equipped) into neutral (“N”) before
starting the engine.
3. Never leave the engine running while
unattended.
4. Never attempt to make any adjustments
while the engine is running, except
where specifically recommended in the
operator’s manual.
Safe Handling of Gasoline:
To avoid personal injury or property damage,
use extreme care in handling gasoline. Gasoline
is extremely flammable and the vapors are
explosive. Serious personal injury can occur
when gasoline is spilled on yourself and/or your
clothes which can ignite. Wash your skin and
change clothes immediately.
1. When adding fuel, turn engine OFF and
let engine cool at least 2 minutes before
removing the gas cap.
2. Fill fuel tank outdoors or in well ventilated
area.
3. Use only an approved gasoline container.
4. Never fill containers inside a vehicle or on
a truck or trailer bed with a plastic liner.
Always place containers on the ground
away from your vehicle before filling.
5. If possible, remove gas-powered
equipment from the truck or trailer and
refuel it on the ground. If this is not
possible, then refuel such equipment on
a trailer with a portable container, rather
than from a gasoline dispenser nozzle.
6. Keep the nozzle in contact with the rim of
the fuel tank or container opening at all
times until fueling is complete. Do not use
a nozzle lock-open device.
7. Do not overfill fuel tank. Fill tank to full
as indicated by the fuel level indicator
installed inside of the fuel tank or marked
on the tank. Do not over-fill to allow space
for fuel expansion. On some models, a fuel
level indicator may NOT be present, in this
instance, fill the tank no more than 1/2
inch below the bottom of the filler neck to
allow space for fuel expansion.
8. Replace fuel cap and tighten until the cap
ratchets.
9. If gasoline is spilled, wipe it off the engine
and the equipment. Move the machine
to another area. Wait five minutes before
starting the engine.
10. To reduce fire hazards, keep the machine
free of grass , leaves or other debris
build up. Clean up oil or fuel spillage and
remove any fuel-soaked debris.
11. Keep gasoline away from sparks, open
flames, pilot lights, heat, and other
ignition sources.
12. Never fuel equipment indoors because
flammable vapors will accumulate in the
area.
13. Extinguish all cigarettes, cigars, pipes, and
other sources of ignition.
14. Check fuel line, tank, cap, and fittings
frequently for cracks or leaks. Replace if
necessary.
Operation
1. When starting the engine, make sure spark
plug, muffler, and fuel cap are in place.
2. Do not crank engine with spark plug
removed.
3. If fuel spills, wait until it evaporates before
starting engine.
4. Allow muffler, engine cylinder, and fins to
cool before touching.
5. Keep children away from hot or running
engines. They can suffer burns from a hot
muffler.
6. Remove accumulated combustibles from
muffler and cylinder area.
7. Operate equipment with all guards in
place.
8. Keep hands and feet away from rotating
parts.
9. Tie up long hair and remove jewelry.
10. Do not wear loose-fitting clothing,
dangling drawstrings or items that could
become caught.
11. When starting the engine, pull cord slowly
until resistance is felt, then pull rapidly (if
not electric start).
12. Remove all external equipment/engine
loads before starting engine.
13. Direct coupled equipment components
such as, but not limited to blades,
impellers, pulleys, sprockets, etc., must be
securely attached.
Loading ...
Loading ...
Loading ...