Loading ...
Loading ...
Loading ...
TROUBLESHOOTING POINTS
CAUSE CORRECTION
PROBLEM
Will not start
Hard to start
Engine will not turn over
Engine clicks but will not
start
Loss of power
Excessive vibration
1. Out of fuel
2. Engine not "CHOKED" properly.
3. Engine flooded.
4. Bad spark plug.
5. Dirty air filter.
6. Dirty fuel filter.
7. Water in fuel.
8. Loose or damaged widng.
9. Carburetor out of adjustment.
10. Engine valves out of ediustment.
1. Dirty air filter.
2. Bad spark plug.
3. Weak or dead battery.
4. D_rryfuel filter.
5. Stale or dirty fuel.
6. Loose or damaged wiring.
7+ Carburetor out of adjustment.
8. Engine valves out of adjustment.
1. Clutch/brake pedal not depmssod.
2. Attachment fflutch is engaged.
3. Weak or dead battery.
4. Btown fuse.
5. Corroded battery terminals.
6. Loose or damaged wiring:
7. Faulty igalfion switch.
8. Faulty solenoid or stader.
9. Faulty operator presence switch(es).
1. Weak or dead battery+
2. Corroded battery terminals.
3. Loose ordamaged widng.
4. Faulty solenoid or starter.
1. Cufflog too much grass/tea fast.
2. Throttle in"CHOKE" position.
3. Build-up of grass, leaves and trash under mower.
4. Dirty air filter.
5. Low oil level/dirty oil.
6. Faulty spark plug.
7. Dirty fuel filter.
8. Stale or dirty fuel.
9+ Waterin fuel.
10. Spark plug wire loose.
11. Dirty engine air screen/fins.
12. Dirty/clogged muffler.
13.
14.
10.
11.
12.
Loose or damaged winng. 13.
Carburetor out of adjustment. 14.
15 Engine valves out of adjustment.
t Worn. bent or loose blade.
2. Bent blade mandrel
3. Loose/damaged part(s)
1. F_IIfuel tank.
2. See "TO START ENGINE" in Operation section.
3. 'Wait several minutes before attempting to start.
4. Replace spark plug.
5. CIssNreplace air filter.
6. Replace fuel filter.
7. Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel fitter.
8. Check all wiring.
9. See "To Adjust Carburetor" in Service Adjustments
section.
10. Co,act an authedzed service center/dapartment.
1. Clean/replace air filter.
2. Replace spark plug.
3. Recharge or replace battery.
4, Replace fuel filter.
5. Drain fuel tank and refill with fresh gasoline.
6. Check all wiling.
7. Sea "To Adjust Carburetor" in Service Adjustments
sec_on.
8. Contact an authedzed service center/dapartmant.
1. Depress elutol'Vbrake pedal.
2. Disengage attachment clutch.
3. Recharge or replace battery.
4. Replace fuse.
5. Clean battery terminals.
6. Check all widng.
7. Check/replace ignition switch.
8. Check/replace solenoid or starter,
9. Contact an authedzod service center/department.
1. Recharge or replace battery,
2. Clean battery terminals.
3. Check all wiring.
4. Check/replace solenoid or starter.
1. Set in =Higher Cut" posi_on/reduce speed.
2. Adjust throttle control.
3. Clean underside of mower housing.
4. Clean/replace air filter.
5. Check oil level/change oil.
6. Clean and regap or change spark plug.
7. Replace fuel filter.
8. Drain fuel tank and refill with fresh gasoline.
9. Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel filter.
Connect and tighten spark plug wire.
Clean engine air screen/fins.
Clean/replace muffler.
Check all wiring.
See "To Adjust Carburetor" in Service Adjustments
section.
15. Contact an authorized service center/department.
1 Replace blade. Tighten blade bolt.
2. Replace blade mandrel.
3. Tighten loose part(s). Replace damaged parts.
27
Loading ...
Loading ...
Loading ...