Loading ...
Loading ...
Loading ...
, , i i H nunH,,,i
STORAGE
i mm n ,H,,m,,i
Immediately prepare your tractor for storage at the end of
the season or if the unit will not be used for 30 days or more.
CAUTION: Never store the tractor with
gasoline In the tank Inside a building
where fumes may reach an open flame
or spark, Allow the engine to cool be-
fore storing in any enclosure,
TRACTOR
Remove mower from tractor for winter storage, When
mower is to be stored for a period of time, clean it thor-
oughly, remove all dirt, grease, leaves, etc, Give blades
and underside of housing a good coat of grease or rust
preventative. Store in a clean, dry area,
• Clean entire tractor (See "CLEANING" in the Mainte-
nance section of this manual).
• Inspect and replace belts, if necessary (See belt re-
placement instructions in the Service and Adjustments
section of this manuat).
, Lubricate as shown in the Maintenance section of this
manual.
• Be sure that alt nuts, bolts and screws are securely
fastened_ Inspect moving parts for damage, breakage
and wear, Replace if necessary,
• Touch up all rusted or chipped paint surfaces; sand
lightly before painting.
BATTERY
• Fully charge the battery for storage.
• After a period of time in storage, battery may require
recharging.
• To help prevent corrosion and power leakage during
long periods of storage, battery cables should be
disconnected and battery cleaned thoroughly (see "TO
CLEAN BATTERY AND TERMINALS" in the Mainte-
nance section of this manual),
• After cleaning, leave cables disconnected and place
cables where they cannot come in contact with battery
terminals,
. Be sure battery drain tube is securely attached to drain
in battery tray.
• Drain the fuel tank.
• Start the engine and let it run until the fuel lines and
carburetor are empty,
• Never use engine or carburetor cleaner products inthe
fuel tank or permanent damage may occur.
• Use fresh fuel next season.
NOTE: Fuel stabilizer is an acceptable alternative in mini-
mizing the formation of fuel gum deposits during storage.
Add stabilizer to gasoline infuel tank or storage container.
Always follow the mix ratio found on stabilizer container_
Run engine at least 10 minutes after adding stabilizer to
allow the stabilizer to reach the carburetor. Do not drain the
gas tank and carburetor if using fuel stabilizer,
ENGINE OIL
Drain oil (with engine warm) and replace with clean engine
oil (See "ENGINE" in the Maintenance section of this
manual),
CYLINDERS
• Remove spark plug(s).
• Pour one ounce of oil through spark plug hole(s) into
cylinder,
• Turn ignition key to "START" position for a few seconds
to distribute oil.
• Replace with new spark plug(s).
OTHER
• Do not store gasoline from one season to another.
• Replace your gasoline can if your can starts to rusL
Rust and/or dirt in your gasoline will cause problems.
• If possible, store your unit indoors and cover it to give
protection from dust and dirt,
, Cover your unit with a suitable protective cover that
does not retain moisture. Do not use plastic. Plastic
cannot breathe which allows condensation to form and
will cause your unit to rust°
IMPORTANT: NEVER COVER TRACTOR WHILE
ENGINE AND EXHAUST AREAS ARE STILL WARM
ENGINE
FUEL SYSTEM
IMPORTANT: IT IS IMPORTANT TO PREVENT GUM
DEPOSITS FROM FORMING IN ESSENTIAL FUEL
SYSTEM PARTS SUCH AS CARBURETOR, FUEL FILTER,
FUEL HOSE, OR TANK DURING STORAGE- ALSO,
EXPERI ENCE INDICATES THAT ALCOHOL BLENDED
FUELS (CALLED GASOHOL OR USING ETHANOL OR
METHANOL) CAN ATTRACT MOISTURE WHICH LEADS
TO SEPARATION AND FORMATION OF ACIDS DURING
STORAGE ACIDIC GAS CAN DAMAGE THE FUEL
SYSTEM OF AN ENGINE WHILE IN STORAGE,
25
Loading ...
Loading ...
Loading ...