Assemble your grill on a level, protective surface to prevent damage to the unit. The outer carton is ideal for this purpose. Place the carton top side up. Cut all 4 corners with a utility knife and allow the carton panels to lay flat, as shown
2.
3.
NOTE: Do not fully tighten wheel brackets 26 &27
4.
5.
NOTE: Fully tighten wheel brackets from step 3.
6.
While holding the Temperature Gauge in desired position, use this nut to tighten the Temperature Gauge. DO NOT use the face of the temperature gauge to tighten.
7.
8.
9.
10.
11.
12.
Safety Warnings
CAUTION: Indicates a potentially hazardous situation or unsafe practice which, if not avoided, may result in minor or moderate injury.
CAUTION
Read and follow all safety statements, assembly instructions, and use and care directions before attempting to assemble and cook.
For residential use only. Do not use for commercial cooking.
Some parts may contain sharp edges! Wear protective gloves if necessary.
THIS UNIT IS HEAVY! DO NOT attempt to assemble without a helper.
This unit should be assembled on a level, stable surface.
When cooking, the unit must be on a level, stable surface in an area clear of combustible material.
WARNING
CARBON MONOXIDE HAZARD Burning charcoal inside can kill you. It gives off carbon monoxide, which has no odor. NEVER burn charcoal inside homes, vehicles, or tents.
Failure to follow all manufacturer’s instructions could result in serious personal injury and/or property damage.
Ash catcher pan must be fully installed during operation. Failure to properly install could result in hot embers falling from grill.
Most surfaces on this unit are hot when in use. Use extreme caution. Keep others away from unit. Always wear protective clothing to prevent injury.
Keep children and pets away.
Do not move this unit during operation.
Never substitute gasoline, kerosene or alcohol for charcoal starter. In some states, the use of charcoal starter is prohibited by law. In this case, paraffin-based starter cubes can be substituted for charcoal starter. Never use charcoal starter fluid with an electric starter.
All surfaces can be hot during use. Use protection as required to prevent burning.
Do not use this unit on or near combustible surfaces or structures such as wood decks, dry leaves or grass, vinyl or wood siding, etc.
FAILURE TO READ AND FOLLOW INSTRUCTIONS FOR LIGHTING CHARCOAL MAY RESULT IN SERIOUS PERSONAL INJURY AND OR PROPERTY DAMAGE.
ALWAYS USE CAUTION WHEN HANDLING HOT COALS TO PREVENT INJURY.
ALWAYS LIGHT THE FIRE WITH THE GRILL LID OPEN.
After a charcoal fire appears extinguished, unconsumed embers can retain heat for up to 24 hours, and if exposed to fresh air, can burst into flame unexpectedly. Any such embers outside the firebox of the grill pose a fire hazard and can ignite combustible surfaces such as wooden decks.
Use grill at least 3 ft. from any wall or surface. Maintain 10 ft. clearance to objects that can catch fire or sources of ignition such as pilot lights on water heaters, live electrical appliances, etc.
Use grill only in well-ventilated space. NEVER use in enclosed space such as carport, garage, porch, covered patio, or under an overhead structure of any kind.
