Loading ...
Loading ...
Loading ...
25
4. Apply masking tape to the end of a
9
⁄32" (7 mm) nut driver
to help hold the gas orice spud in the nut driver while
changing it. Press nut driver down onto the gas orice
spud and remove by turning it counterclockwise and lifting
out. Set gas orice spud aside.
A
B
C
D
A. Igniter electrode
B. Orice spud
C. Orice spud holder
D. Screws
5. Gas orice spuds are stamped with a number on the side.
Replace the LP gas orice spud with the correct Natural gas
orice spud.
XXX
A
A. Stamped number
Refer to the following chart for the correct Natural gas orice
spud placement.
Natural Gas Orifice Spud Chart
Burner Rating Color Size (mm) ID Number
19,000 BTU (ST) White/Gray 1.84 184
17,000 BTU (ST) N/A 1.75 175
17,000 BTU White/Blue 1.90 190
15,000 BTU White/Green 1.80 180
9,200 BTU White/Black 1.35 135
8,000 BTU White/Yellow 1.25 125
5,000 BTU White/Orange 1.00 100
1,200 BTU Black 0.52 52
NOTE: Refer to the model/serial/rating plate located on the
oven frame behind the top right-hand side of the oven door
for proper sizing of spuds for each burner location.
6. Place LP gas orice spuds in the orice spud bag.
IMPORTANT: Keep the LP gas orice spuds in case
of reinstallation with LP gas.
7. Replace the burner base.
8. Replace the burner cap.
9. Repeat steps 1 to 7 for the remaining burners.
Complete Installation (LP Gas to Natural Gas)
1. Refer to the “Make Gas Connection” section for proper
connection of the range to the gas supply.
2. Refer to the “Electronic Ignition System” section for proper
burner ignition and operation.
3. Refer to the “Adjust Flame Height” section for burner ame
adjustments.
IMPORTANT: You may have to adjust the low setting for
each cooktop burner.
Checking for proper cooktop burner ame is very important.
Natural gas ames do not have yellow tips.
4. Refer to “Complete Installation” in the “Installation
Instructions” section of this manual to complete this
procedure.
IMPORTANT: Make sure to save the orifices that have
just been replaced in the conversion.
Loading ...
Loading ...
Loading ...