Loading ...
Loading ...
Loading ...
A
WARNING: Operator (and any passenger) of
this Fun-Kart MUST always wear a properly
fitting motorcycle type helmet approved by
agencies such as the Department of
Transportation (DOT), Safety Helmet Council
of America (SHCA), or Snell Memorial
Foundation (SNELL).
, Most Fun-Kart accident fatalities are due to head
injuries.
Operator (and any passenger) should also wear
face shields or goggles, boots, gloves and other
appropriate protective clothing. (See
OPERATION-OPERATING INSTRUCTIONS.)
,_ WARNING: Long hair, loose clothes, or
jewelry can get caught in moving parts below and
behind the seat or surrounding environment.
Remove or tie back anything loose that can reach
below and behind the seat before riding.
A
WARNING: NEVER place hands, feet, any
body parts or clothing near the engine, wheels,
chain and other rotating parts of the Fun-Kart
while riding or running the engine.
Use caution in performing required maintenance
on or near operating engine.
o Use caution after the engine has been running,
since the engine and other drive components
may be extremely hot.
A
li WARNING: NEVER adjust, repair or clean the
Fun-Kart while it is in motion.
d_l_ WARNING: STOP the engine if the Fun-Kart
makes unusual noises or vibrations.
• Checkthe Fun-Kart for damage.
• Excessive noise or vibration is a sign of loose or
worn parts.
_ WARNING: Keep guards and pads in place at
all times.
Prevent accidental contact by the operator or service
personnel while the FUN-KART is running. The
guards over the brake, clutch or torque converter,
axle and drive sprockets also help prevent mud and
debris from coming in contact with those items.
_1= WARNING: Be sure the passenger restraint
system is properly adjusted and fastened at all
times during operation.
If the passenger restraintsystem is not properly
used by the operator and/or passenger, loss of
control and possible personal injury and/or Fun-
Kart damage can occur.
_li_ WARNING:When there is no passenger in a
two seat kart, the passenger's seatbelt must be
securely fastened within the Fun-Kart.
• Unused and unsecured seat belts pose a safety
risk by snagging on the surrounding environment
or becoming entangled in the running gear of the
Fun-Kart.
_ WARNING: All screws, nuts and bolts must
be properly tightened to make sure the FUN-
KART is in safe operating condition.
NOTE: Overtightening hardware where parts are
required to move, such as front wheels, spindles, a-
arm pivots, etc., can restrict movement and cause a
loss of control and possible injury.
_ WARNING: Prevailing-torque-type Iocknuts
must be replaced with new after the old Iocknuts
have been removed.
Replace with the same type of Iocknut to make sure
they function properly. Refer to the maintenance
section for more information on Iocknuts.
_1_ WARNING: Keep the engine free of dirt and
debris, especially in the throttle linkage area.
,_ WARNING: NEVER start the engine without
checking to see that the throttle control is in idle
position and parking brake is set.
_k WARNING: NEVER start the engine without
the operator properly seated and the restraint
system properly adjusted and secured.
_ WARNING: NEVER tamper with, alter or
change the Fun-Kart's engine governor settings,
The governor as set by the engine manufacturer,
limits maximum engine speed and protects the
engine from damage.
Excessive engine speed is potentially dangerous
to operator, passenger, bystanders and engine.
Loading ...
Loading ...
Loading ...