Loading ...
Loading ...
Loading ...
TROUBLESHOOTI POINTS
CAUSE CORRECTION
,11
PROBLEM
Will not start
Hard to start
IHHH' 'H '"""'I lU
Engine will not turn over
Engine clicks but wtll not
start
Lose of power
Excessive vibration
1 Out of fuel
2 Engine not "CHOKED" properly
3 Engine flooded
4 Bad spark plug
5 Dirty air filter.
6, Dirty fuel filter
7. Water tn fuel
8. Loose or damaged Wiring
9 Carburetor out of adjustment.
10 Engine valves out of adjustment,
i ,Hi
1 Dirty air filter
2 Bad spark plug.
3 We_k or dead battery
4 D_rty fueI filter
5 Stale or dirty fuel
6 Loose or damaged wiring
7, Carburetor out of adjustment-
8 Engine valves out of adjustment,
1 Clutch/brake pedal not depressed
2, Attachment clutch ts engaged,
3 Weak or dead battery
4 BIawn fuse
5 Corroded battery terminals
6 Loose or damaged wiring.
7 Faulty ignition switch.
8 Faulty sofenoid or starter
9 Faulty operator presence switch(es)
1 Weak or dead battery.
2 Corroded battery terminals
3 Loose or ,damaged wiring
4 Faulty solenotd or starter
1 Cutting too much grass/too fast,
2 Throttle in "CHOKE" position.
3 Build-up of grass, leaves and trash under mower
4 Dirty air filter
5 Low oil level/dirty oil
6 Faulty spark pfug
7 Dirty fue_ filter
8 Stale or dirty fuel
9 Water in fuel
10 Spark plug wire loose
11 Dirty engine air screen!fins
12 Dirty/c_ogged muffler.
13 Loose or damaged wiring
14 Carburetor out of adjustment
15. Engine valves out of adjustment,
1 Worn, bent or loose blade,
2 Bent blade mandrel
3 Loose/damaged part(s)
1, FIll fuel tank.
2, See "TO START ENGINE" in Operation section.
3 Wait several minutes before attempting to start.
4, Replace spark ptug
5 Clean/replace air filter
6, Replace fuet filter
7. Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel filter.
8. Check attwirlng
9 Contact Sears Service Center/Department,
10 Contact Sears Service Center/Department,
1 Clean!replace air filter
2 Replace spark p_ug
3 Recharge or replace battery
4 Replace fuel filter
5, Drain fuel tank and refitt with fresh gasonne
6 Check nil wiring
7, Contact Sears Service CentedDepartment
8 Contact Sears Service Center/Department,
1, Depress clutch/brake pedal,
2 Disengage attachment clutch,
3, Recharge or reptace battery
4 Replace fuse.
5 Clean battery terminals
6 Check at_wiring
7 Check!replace Ignition switch
8 Check/replace soJenold or starter,
9 Contact Sears Service Center/Department
1 Recharge or reptace battery
2, Clean batteryterminais
3 Check al_wir;_ng
4 Check/replace solenoid or starter
1 Set in "Higher Cut" position/reduce speed.
2, Adjust throttle control
3 Clean underside of mower housing
4 Cteantrep)ace air fiiter
5 Check oil leve!/change oil,
6 Clean and regap or change spark plug
7 Replace fuel filter
8 Drain fuel tank and refill with fresh gasoitne
9 Drain fuel tank and carburetor, reflt_ tank with fresh
gasotine and repiace fuel fitter
10 Connect and tighten spark pfug wire,
11 Clean engine alr screen/fins
12 Clean/replace muffler
t3 Check all Wffingr
14" Contact Sears Service Center/Department
t 5 Contact Sears Service Center/Department.
1 Replace blade Tighten blade best,
2 Replace blade mandrel.
3 Tighten loose part{s) Replace damaged parts.
25
Loading ...
Loading ...
Loading ...