Loading ...
Loading ...
Loading ...
TROUBLESHOOTING POINTS
CAUSE CORRECTIONPROBLEM
Will not start
Hard to start
Engine will not turn over
Engine clicks but will not
start
Loss of power
Excessive vibration
1 Out offuel
2 EngIne not "CHOKED" pmperly
3 Engtne fioodsd_
4 Bad spark plug
5 Dirtyair tilter
6 Dirtyfuel filter
7 Water in fuel
8 Loose or damaged wiring
9 Carburetor out of adjustment
10 Engine valves out of adjustment
1 Dirty air filtar
2. Bad spark plug
3 Weak or dead battery
4 Dirty fue! filler
5 Stale or dirty fuel
6 Loose or damaged wiring,
7 Carburetor out of adjustment
8 Engine valves out of adjustment
1 Clutch/brake peda! not depressed.
2 Attachment clutchis engaged
3 Weak or dead battery
4 Blown fuse
5 Corroded battery terminals
6 Loose or damaged wiring.
7 Faulty ignition switch
B Faulty solenoid or starter
9. Faulty operator presence switch(es)_
1 Weakor dead battery
2 Corroded batteryterminals
3 Looseor damaged wiring
4 Faultysolenoid or starter
1 Cutting too much grass/too fast.
2 Throttle in "CHOKE" position.
3 Build-up of grass, leaves and trash under mower
4 Dirty air filter,
5. Low oil level/dirty oil
6 Faultysparkp]ug
7 Dirty rue] filter
8 Stale or dirty fuel
9 Water in fuel
10 Spark plugwtreloose,
11. Dirty engine air screen/tins
12 Dirty/clogged muffler,
13 Loose ordamaged wiring
14 Carburetor out of adjustmenL
15 Engine valves outof adjustment
1 Worn, bent orlooseblade
2 Bentblade mandrel
3 Loose/damagedpart(s)
1 Fill fuel tank
2 See "TO START ENGINE" in Operation section
3 Wait several minutes before attempting to start
4 Replace spark plug.
5 Clean/reptace air filter
6 Replace fuel filter
7, Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel tilter
8 Check all w_ring
9_ Contact an authorized service center/department
10 Contact an authorized service center/department
1 Clean/replace air filter
2 Replace spark plug
3 Recharge or replace battery
4 Replace fuel filter
5 Drain fuel tank and refill with fresh gasoline
6. Check all wiring
7_ Contact an authorized service canter/department
8 Contact an authorized service center/department
1 Depressclutch/brake pedal
2 Disengage attachment clutch
3 Recharge or replace battery
4 Replacefuse
5 Clean batteryterminals
6 Check all wiring
7 Check/replace ignitionswitch
8 Check/replace solenoid or starter
9 Contact an authorized service center/department
1 Recharge or replace battery
2 Clean battery terminals
3 Check al! wiring_
4 Check/replace solenoid or starter
1 Set in "Higher Cut" position/reduce speed
2 Adjust throttle contro]
3 Ctaan underside of mower housing
4 Clean/replace air filter
5. CheckollleveVchange oil.
6 Clean and regap or change spark plug
7. Replace fuel filter
8 Drain fuel tank and refill with fresh gasoline
9 Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel filter
10 Connect and tighten spark pfug wire.
11 Clean engine air screen/tins
12. Clean/replace muffler
l& Check all wiring
14 Contact an authorized service center/department
15 Contact an authorized service center/department
1 Replace blade Tighten blade bolt
2. Replace blade mandrel
3 Tightenloose part(s) Replace damaged parts
28
Loading ...
Loading ...
Loading ...