Loading ...
Loading ...
Loading ...
TROU LESHOO NG POINTS
PROBLE_ CAUSE CORRECTION
Wiif not start
1. Out of fuel.
2. Engine not "CHOKED" properly,
3, Engine flooded.
4. Bed spark piug.
5. Dirty air filter,
6, Dirty fue! filter,
7, Water in fuel,
8, Loose or damaged wiring.
9. Carburetor out of adjustment,
Hard to start
Engine will not turn over
I0. Engine valves out of adjustment.
1. Dirty air filter,
2, Bad spark p!ug.
3, Weak or dead battery.
4, Dirty fuel filter.
5. Stale or dirty fuel.
6. Loose or damaged wiring.
7, Carburetor out of adjustment.
1. FilI fuel tank.
2, See "TO START ENGINE" in Operation section.
3. Wait several minutes before attempting to start.
4. Replace spark plug.
5, Clean/replace air filter.
6, Repface rue! filter.
7, Drain fue! tank and carburetor, refil_ tank with fresh
gasoline and repiace fuel fiffe_.
8. Checkal! wiring,
9. See "To Adjust Carburetor" in Service Adjustments
section.
10, Contact an authorized service center/department.
Engine clicks but will not
start
Loss of power
8, Engine valves out of adjustment.
t, Clutch/brake pedal not depressed.
2. Attachment clutchis engaged,
3, Weak or dead battery.
4. Blown fuse.
5. Corroded battery terminals.
6, Loose or damaged wiring.
7. FauRy ignition switch,
8. Fautty sofenoid or starter.
9, Faulty operator presence switch(es).
1, ,Weak or dead battery.
2. Corroded batteryterminais,
3, Loose or damaged wiring,
4, Faulty so{enoid or starter.
1, Clean/replace air filter,
2. Replace spa_kplug,
3. Recharge or replace battery.
4, Replace fuel filter,
5, Drain fuel tank and refil} with fresh gasoline,
6, Checkali wiring.
7. See "To Adjust Carburetor" in Service Adjustments
section,
8, Contact an authorized service center/department.
!. Cutting too much grass/too fast,
2. Throttle in"CHOKE" position.
3. Build-up of grass, leaves and trash under mower.
4, Dirty air filter.
1, Depress clutch/brake pedal,
2. Disengage attachment clutch,
3, Recharge or replace battery,
4. Replace fuse.
5, Clean battery terminals.
6. Check ail wiring,
7. Check/replace ignition switch,
8, ChecWreplace solenoid or starter.
9. Contact an authorized service center/department,
Excessive vibration
5. Low oil ievelldirty oil.
6. Faulty spark plug.
7, Dirty fuel filter.
8. State or dirty fuel.
9. Water in fuel.
10, Spark plug wire loose.
11, Dirty engine air screen/fins,
12, Dirty/clogged muffler.
13. Loose or damaged wiring,
t4. Carburetor out of adjustment,
1, Recharge or replace battery,
2, Clean battery terminals.
3, Check alt wiring.
4. Checldreplace solenoid or starter.
1. Set in "Higher Cut" posRionireduce speed.
2. Adjust throttle control.
3. Clean underside of mower housing.
4, Clean/replace air filter.
15. Engine valves out of adjustment.
1, Worn, bent or loose blade,
2. Bent blade mandrel,
3. Loose/damaged part(s).
5. Check oil level/change oii.
6, Clean and regap or change spark ptug.
7. Replace fuel filter,
8. Drain fuei tank and refill with fresh gasoline,
9, Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel filter.
10. Connect and tighten spark pfug wire.
11. Clean engine air screen/fins.
12, Clean/replace muffler.
13. Check all wiring.
14, See "3"o Adjust Carburetor'' in Service Adjustments
section.
t5. Contact an authorized service center/department,
1. Replace blade. Tighten blade bolt.
2. Replace blada mandrel,
3. Tighten loose part(s}. Replace damaged parts,
28
Loading ...
Loading ...
Loading ...