Loading ...
Loading ...
Loading ...
Follow the service and maintenance procedures given throughout this manual and in component
literature shipped with the boiler. Failure to perform the service and maintenance could result in
damage to the boiler or system. Failure to follow the directions in this manual and component lit-
erature could result in severe personal injury, death or substantial property damage.
is product contains berglass jacket insula-
tion and ceramic ber materials in combustion
chamber lining or base panels in gas red
products. Airborne bers from these materials
have been listed by the State of California as a
possible cause of cancer through inhalation.
e combustion chamber lining or base insu-
lation panels in this product contain ceramic
ber materials. Ceramic bers can be con-
verted to cristobalite in very high temperature
applications. e International Agency for
Research on Cancer (IARC) has concluded,
“Crystalline silica inhaled in the form of quartz
or cristobalite from occupational sources is
carcinogenic to humans (Group 1).”:
Suppliers of berglass wool products recom-
mend the following precautions be taken when
handling these materials:
• Avoid breathing berglass dust and contact with skin
or eyes.
• Use NIOSH certied dust respirator (N95). is type
of respirator is based on the OSHA requirements for
berglass wool at the time this document was written.
Other types of respirators may be needed depending
on the job site conditions. Current NIOSH recom-
mendations can be found on the NIOSH web
site at http://www.cdc.gov/niosh/homepage.
html. NIOSH approved respirators, manufac-
turers, and phone numbers are also listed on
this web site.
• Wear long-sleeved, loose fitting clothing,
gloves, and eye protection.
• Apply enough water to the combustion
chamber lining or base insulation to prevent
airborne dust.
• Remove combustion chamber lining or base
insulation from the boiler and place it in a
plastic bag for disposal.
• Operations such as sawing, blowing, tear out
and spraying may generate airborne ber
concentration requiring additional protection.
Bag for disposal.
• Wash potentially contaminated clothes
separately from other clothing. Rinse clothes
washer thoroughly.
• Eye: Irrigate immediately
• Breathing: Fresh air.
Annual service and start-up(continued)
Address reported problems
1. Inspect any problems reported by owner and correct
before proceeding.
Inspect boiler area
1. Verify that boiler area is free of any combustible
materials, gasoline and other ammable vapors and
liquids.
2. Verify that air intake area is unobstructed and free of
corrosive contaminants. If any of these are present in
the boiler intake air vicinity, they must be removed.
Inspect boiler interior
1. Loosen the Control Pod cover retaining screw and
open the cover.
2. Inspect controls and wiring to verify all are in good
condition.
3. Check for any possible leaks that might have dripped
water on the wiring or controls.
4. Inspect the boiler insulation blanket.
5. If inspections show possible leaks, nd and correct
the cause of the leaks.
6. Ensure baes are installed in inside ueways.
Part number 550-143-013/0621
26
Series 3
Loading ...
Loading ...
Loading ...