Loading ...
Loading ...
Loading ...
TROUBLESHOOTING POINTS
PROBLEM
-- =
Will not start
Hard to start
Engine will not turn over
Engine clicks but will not
start
Loss of power
Excessive vibration
CAUSE
1. Out of fuel.
2. Engine not "CHOKED" properly.
3. Engine floode¢
4. Bad sparkplug.
5. Dirty air filter.
6. Dirty fuelfiger
7. Water in fuel.
8. Loose or damaged widng.
9. Carburetor out of aaiustment.
10. Engine valves out of adjustmenl
1 Dirty air filter,
2 Bad seark plug.
3 Weak or dead battery.
,1 Dirty fuel filter.
5. Stale or dtrty fuel.
6 Loose or damaged widng.
7. Carburetor out of adjustment.
8 Engine vatves out of adjustment.
f. Clutch/brake 3edal not denressed
2. Attachment clutch is engagea.
3. Weak or dead battery
4. BIown fuse.
5. Corroded battery [ermma_s
6. Loose or damagea wlnng.
7. Faulty ignition swacn.
8. Faulty solenoid or starter.
9. Faulty oeerator presence switcl esl.
t. Weak or dead battery
2. Corroded battery termmals.
3. Loose or damaged wiring.
4. Faulty solenoid or starer.
Cutting too mucn grass/too fast,
2. Throttle n "CHOKE" position
3. Build-up of grass, leaves and trash under mower.
_t Dirty air filter.
5 Low oil level/dirty oil.
6 =aulty spark ptug.
7 Dirty fuel filter.
8 Stale or dirty rue
9 Water in fuel.
10. Spark plug wire loose.
11. Dirty engine air screen/fins.
12 Dirty/clogged muffler
13. Loose or damaged wiring
14 Carburetor out of adjus[ment.
15 Engine valves out of adjustment.
l Worr Dent or loose Diode.
2 Bent blade manare
3. Loose/damaged 3ares
CORRECTION
1 Fill fuel tank.
2. See "TO START ENGINE" in Oeeratlon section.
3, Wait several minutes before attempting to start.
a Reolace seark plug,
5. Clean/feE ace air fitter.
6. Replace fuel filter.
7. Drain fuel tank and carburetor refill tank with fresh
gasoline and replace fuel filter.
8, Check all wiring.
9. Contact an authorized service center/department
10. Contact an autnorlzea service center/deBaRment
1 Clean/replace air filter,
2. Reelace spark plug.
3, Recharge or replace eattery.
4, Replace tus Iilter
5, Drain fuel tank and refill with tresf gasoline.
6. Check all wiring,
7 Contact an autnonzea service center/department
8, Contact an aumonzed service center/department
1 3eDress clutch/brake pedal
2 Disengage a[tacnment clut@
3 Recharge or replace eattery.
4 Replace fuse.
5 Clean battery [ermina{s.
6 Check all wiring.
7 Check/replace _gnition switch
8 CheckireB ace solenoid or starter.
9 Contact an authorized service center/department.
1. Recharge or replace battery.
2. Clean batter, [ermma_s,
3. Check all wJdng.
4. Check/rat ace solenoid or starter
t. Set in _Higher Cut" 3osition/reduce sDeea
2. Adjust throttle control.
3 Clean underside of mower housing
,t Clean/replace air filter
5. Check oil level/change o
6. Clean and regap or change spark plug.
7. Replace fuel fiJter,
8. Drain fuel tank anG rel with fresh gasotme.
9. Drain fuel tank and carburetor refill tank wif_" fresl-
gasoline and reolace fuel Nter.
10 Connect and tighten spark plug wLre
11. Clean engme air screen/fins
12. Clean/replace muffler.
13. Check allwiring.
14. Contact an authorized service center/deoartment.
15. Contact an authorized service center/department.
1 Replace blade Tighten blade bolt
2. Replace blade mandre
3. Tighten loose part(s). Replace damaged Darts.
_ -- =
27
Loading ...
Loading ...
Loading ...