Loading ...
Loading ...
Loading ...
27
ELECTRONIC CONTROL SETUP INSTRUCTIONS
IMPORTANT
Electrostatic Discharge (ESD)
Sensitive Electronics
ESD problems are present everywhere. ESD may damage
or weaken the electronic control assembly. The new control
assembly may appear to work well after repair is finished,
but failure may occur at a later date due to ESD stress.
■
Use an anti-static wrist strap. Connect wrist strap to
green ground connection point or unpainted metal in the
appliance.
-OR-
Touch your finger repeatedly to a green ground connection point
or unpainted metal in the appliance.
■
Before removing the part from its package, touch the
anti-static bag to a green ground connection point or
unpainted metal in the appliance.
■
Avoid touching electronic parts or terminal contacts;
handle electronic control assembly by edges only.
■
When repackaging failed electronic control assembly in
anti-static bag, observe above instructions.
General User Information
BLANK DISPLAY – This condition indicates the dryer is inoperative.
Enter setup mode to view diagnostic code.
“0 MINUTES” SHOWING IN DISPLAY – This indicates the cycle
is complete and the dryer cannot be operated. Coins dropped or
debit inputs during this condition will be stored in escrow but cannot
be used until normal operation is restored by opening and closing
the door. If a door switch has failed, it must be replaced before
normal operation can be restored.
COLD START (Initial first use) – Dryer is programmed at the
factory as follows:
5 minutes dry time/quarter (coin 1)
$1.50 dry price (fixed cycle with top off – Coin Models)
$0.00 dry price (fixed cycle – Non-Coin / Card-Ready Models)
WARM START (after power failure) – A few seconds after power
is restored, if a cycle was in progress at the time of the power failure,
“RESELECT CYCLE” will flash in the display, indicating a button
needs to be pressed to restart dryer.
PRICING – After the door is opened and then closed following the
completion of a cycle, the display indicates the cycle price
(unless set for free operation). As coins are dropped or debit inputs
arrive, the display will change to lead the user through the initiation of
a cycle.
There are four (4) types of dryer pricing:
Fixed “Vend” Pricing
A dryer set up for “Fixed Cycle” operation can only accept additional
time accumulated by increments equal to the length of a complete
dry cycle. A maximum number of minutes may be purchased; no
additional credit is given for coins dropped when the maximum
minutes are displayed.
Accumulator Pricing
If the price is set to one coin 1, then accumulator pricing is in effect
(stacked Coin models also require Fixed Cycle with Top Off option to
be selected). Cycle time can be purchased one coin at a time
(Coin models) up to the maximum time. Stacked Coin models
will credit all money to a cycle with a single button press while in
accumulator pricing.
Fixed Cycle With Top Off Pricing
A dryer set to offer “Top Off” capability will allow time to be added to
an existing dry cycle in increments equal to the number of minutes of
dry time per quarter (coin 1), up to the maximum minutes, regardless
of the cost required to start the dryer. No credit is given for coins
or debit inputs entered when the control is displaying the maximum
minutes.
Non-Coin / Card-Ready Models: In Enhanced Debit Mode, the top
off price can be set independently. (See VALUE OF COIN 2), and
the top off time is calculated according to the following equation:
top off price top off time
full cycle price full cycle length
Penny increment offset is not applied to top off purchases.
FREE CYCLES – This is established by setting the cycle price to
zero. When this happens, “SELECT CYCLE” will appear rather than
a cycle price. Any cycle started as a free cycle will automatically
terminate when the door is opened.
DEBIT CARD READY – This dryer is debit card ready. It will accept
a variety of debit card systems, but does NOT come with a debit
card reader. Refer to the debit card reader manufacturer for proper
dryer setup. In models converted to a Generation 1 debit card
system, debit pulses represent the equivalent of one coin (coin 1).
Display
After the dryer has been installed and plugged in, the display will
show “0 minutes.”
Stacked Non-Coin / Card-Ready Models
UPPER DRYER
WHITES
& COLORS
DELICATES
LOWER DRYER
HIGH HEAT
PERMANENT
PRESS
MEDIUM HEAT LOW HEAT
WHITES
& COLORS
DELICATES
HIGH HEAT
PERMANENT
PRESS
MEDIUM HEAT LOW HEAT
0
MINUTES
0
MINUTES
Once the unit has been plugged in and the dryer door opened and
closed, the display will show the price. In Non-Coin / Card-Ready
models set for free cycles, the display will flash “SELECT CYCLE”
(not shown).
Stacked Coin Models
1.50
PRICE
1.50
PRICE
UPPER DRYER
WHITES
& COLORS
DELICATES
LOWER DRYER
HIGH HEAT
PERMANENT
PRESS
MEDIUM HEAT LOW HEAT
WHITES
& COLORS
DELICATES
HIGH HEAT
PERMANENT
PRESS
MEDIUM HEAT LOW HEAT
Loading ...
Loading ...
Loading ...