Napoleon GVF42-1N User Manual

Loading ...

4.2

THIS GAS APPLIANCE SHOULD BE INSTALLED AND SERVICED BY A QUALIFIED INSTALLER to

conform with local codes. Installation practices vary from region to region and it is important to know the

speciﬁcs that apply to your area, for example in Massachusetts State:

• This product must be installed by a licensed plumber or gas ﬁtter when installed within the commonwealth of

Massachusetts.

• The appliance off valve must be a “T” handle gas cock.

• The ﬂexible connector must not be longer than 36” (91.4cm).

• A Carbon Monoxide detector is required in all rooms containing gas ﬁred appliances.

• The appliance is not approved for installation in a bedroom or bathroom unless the unit is a direct vent

sealed combustion product.

• Un-vented room appliances shall be installed in accordance with 527 CMR 30.00 and 248 CMR 3.00

through 7.00.

• Sellers of un-vented propane or natural gas-ﬁred space / room appliances shall provide to each purchaser a

copy of 527 CMR 30.00 upon the sale of the appliance from http://www.napoleonﬁ replaces.com/Webshare/

installation_manuals/mass_requirements.pdf

In absence of local codes, install the appliance to the current National Fuel Gas Code, ANSI Z223.1 Installation

Code which can be obtained from:

American National Standards Institute Inc. or National Fire Protection Association Inc.

1430 Broadway Batterymarch Park

New York, NY 10018 Quincy, MA 02269

The appliance and its individual shutoff valve must be disconnected from the gas supply piping system during

any pressure testing of that system at test pressures in excess of 1/2 psig (35 mb). The appliance must be

isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure

testing of the gas supply piping system at test pressures equal to or less than 1/2 psig (35 mb). When installed

with a blower or fan, the junction box must be electrically connected and grounded in accordance with local

codes. In the absence of local codes, use the current ANSI / NFPA 70 National Electric Code. In the case

where the blower is equipped with a power cord it must be connected into a properly grounded receptacle. The

grounding prong must not be removed from the cord plug.

As long as the required clearance to combustibles is

maintained, the most desirable and beneﬁ cial location for

the appliance is in the center of a building, thereby allowing

the most efﬁ cient use of the heat created. The location of

windows, doors and the trafﬁ c ﬂ ow in the room where the

appliance is to be located should be considered.

If the appliance is installed directly on carpeting, vinyl tile

or other combustible material other than wood ﬂ ooring,

the appliance shall be installed on a metal or wood panel

extending the full width and depth.

Air shortage caused by an inadequate air supply, improper log positions, the addition of foreign or unapproved

materials or the failure to properly maintain the appliance, may result in incomplete combustion of the fuel.

Incomplete combustion results in soot being deposited inside the ﬁ rebox as well as surfaces outside the

appliance. If any soot deposits are observed, shut off the appliance immediately and arrange for it to be serviced

by a qualiﬁ ed technician.

We suggest that our gas

hearth products be installed

and serviced by professionals

who are certied in the U.S.

by the National Fireplace

Institute

(NFI) as NFI Gas

Specialists

www.ncertied.org

This does not apply to stoves.

note:

1.3 rating plate information

This illustration is for reference only. Refer to the rating plate on the appliance for accurate information.

CERTIFIED UNDER: ANSI Z21.11.2a-2008 VOLUME II, UNVENTED ROOM HEATER

W385-0248 / H

SERIAL NUMBER: G/CVF42

WOLF STEEL LTD.

24 NAPOLEON ROAD, BARRIE, ON, L4M 0G8 CANADA

THIS APPLIANCE MAY BE INSTALLED IN AN AFTERMARKET,

PERMANENTLY LOCATED, MANUFACTURED (MOBILE) HOME, WHERE

NOT PROHIBITED BY LOCAL CODES. THIS APPLIANCE IS ONLY FOR USE

WITH THE TYPE OF GAS INDICATED ON THE RATING PLATE. THIS

APPLIANCE IS NOT CONVERTIBLE FOR USE WITH OTHER GASES.

THIS IS A GAS-FIRED UNVENTED ROOM HEATER THAT REQUIRES

ADEQUATE COMBUSTION AND VENTILATION AIR. THIS APPLIANCE

IS NOT APPROVED FOR BEDROOM, BATHROOM AND BED-SITTING

ROOM INSTALLATION.

GVF42-N / CVF42-N MODEL GVF42-P / CVF42-P

**0-2000FT (0-610m) ALTITUDE 0-2000FT (0-610m)**

30,000 BTU/h INPUT 30,000 BTU/h

22,000 BTU/h REDUCED INPUT 22,000 BTU/h

MANIFOLD PRESSURE: 3.5" WATER COLUMN MANIFOLD PRESSURE: 10" WATER COLUMN

MINIMUM SUPPLY PRESSURE: 4.5" WATER COLUMN MINIMUM SUPPLY PRESSURE: 11" WATER COLUMN

MAXIMUM SUPPLY PRESSURE: 7.0" WATER COLUMN MAXIMUM SUPPLY PRESSURE: 13" WATER COLUMN

SIT CONTROL: #820637 SIT CONTROL: #820636

OPERATING PILOT OXYPROTECTOR: #8214 OPERATING PILOT OXYPROTECTOR: #8404

** ABOVE 2,000FT, CONSULT LOCAL AUTHORITY HAVING JURISDICTION

NOT FOR USE WITH SOLID FUEL.

WARNING: APPLIANCE SCREENS MUST BE CLOSED WHILE IN OPERATION. DO NOT ADD ANY MATERIAL TO THE APPLIANCE, WHICH WILL COME IN

CONTACT WITH THE FLAMES, OTHER THAN THAT SUPPLIED BY THE MANUFACTURER WITH THE APPLIANCE. DO NOT USE BLOWER INSERT, HEAT EXCHANGER INSERT, OR OTHER

ACCESSORIES NOT APPROVED FOR USE WITH THIS HEATER. IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR MAINTAINANCE CAN CAUSE PROPERTY DAMAGE, PERSONAL

INJURY, OR LOSS OF LIFE. REFER TO THE OWNER'S INFORMATION MANUAL PROVIDED WITH THIS APPLIANCE. INSTALLATION AND SERVICE MUST BE PERFORMED BY A QUALIFIED INSTALLER,

SERVICE AGENCY OR THE GAS SUPPLIER.

MINIMUM CLEARANCE TO COMBUSTIBLE MATERIALS:

TOP / SIDES / BACK / FLOOR 0”

RECESSED DEPTH 22“

MANTEL 2”*

MAXIMUM HORIZONTAL EXTENSION: 2". SEE INSTRUCTION MANUAL FOR GREATER

EXTENSIONS.

ELECTRICAL RATING: 115V 0.82AMP, 60HZ

OPTIONAL FAN KIT: GZ550-KT

9700539 (WSL) 4001657 (NGZ)

4001658 (NAC) 4001659 (WUSA)

MATERIAL: CLASS III A-2, PERMANENT LABEL, 2 MIL MATERIAL, 1 MIL ADHESIVE, 3 MIL TOTAL THICKNESS, COMPUCAL WATERPROOF, NON-WATER SOLUBLE ADHESIVE,

CAPABLE OF WITHSTANDING A MAXIMUM TEMPERATURE OF 175° F (79° C).

MIN. LETTERING FOR "NOT FOR USE WITH SOLID FUEL.", "UN COMBUSTIBLE SOLIDE NE DOIT PAS ETRE UTILISE AVEC CELUI." TO BE 10 POINT ARIAL, BOLD FACE,

UPPER CASE AND 2 POINT LEADING SPACING OR EQUIVALENT.

SILVER LETTERING ON BLACK BACKGROUND

MAX OVERALL DECAL SIZE: 8" x 4”

SERIAL NUMBERS TO BE ASCENDING FROM G/CVF42000001

TITLE: RATING PLATE GVF42 / CVF42

REVISION: H: CORRECTED ADHESIVE TEMP LIMIT || 09.27.16_JK

DWG#: W385-0248

DATE: 10.01.01

SAMPLE

The rating plate must remain with the appliance at all times. It must not be removed.

note:

1.4 mobile home installation

Suitable for mobile home installation where the mobile home has been permanently placed on its site. This appli-

ance must not be installed in a bedroom or bathroom.

This appliance may be installed in an aftermarket permanently located, manufactured (mobile) home, where not

prohibited by local codes.

W415-0379 / G / 08.23.18

general information

Loading ...

Napoleon GVF42-1N Grandville VF42

User Manual - Page 8