Sealey AK2923 Cordless Glue Gun 3.7V

CORDLESS GLUE GUN 3.7V

MODEL NO: AK2923

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,

and properly maintained, give you years of trouble free performance.

1. SAFETY

 WARNING!Alwayswearapprovedeyeorfaceprotectionwhenoperatingthegluegun.

9  Keeptheworkareaclean,unclutteredandensurethereisadequatelighting.

9  Removeillttingclothing.Removeties,watches,rings,andotherloosejewellery,andcontainand/ortiebacklonghair.

9  Maintaincorrectbalanceandfooting.Ensuretheoorisnotslipperyandwearnon-slipshoes,

9  Securenonstableworkpiecewithaclamp,viceorotheradequateholdingdevice.

8 DO NOTtouchthehotnozzleorthesiliconcap.

8 DO NOTusethegluegunforataskitwasnotdesignedtoperform.

8 DO NOT operatethegluegunifanypartsaredamagedormissingasthismaycausefailureand/orpossiblepersonalinjury.

8 DO NOT holdtheworkpiecebyhand.Useclampsoravice(notincluded)tosecuretheworkpiece.AvailablefromyourSealeystockist.

8 DO NOT getthegluegunwetoruseindamporwetlocationsorareaswherethereiscondensation.

8 DO NOTusethegluegunwherethereareammableliquids,solidsorgasessuchaspaintsolvents,etc.

8 DO NOTleavethegluegunoperating/heatingupunattended.

9  Protectworksurfacefromgluespiltduringwarmupphaseandwhilstbeingused.

9  Afteruseplacethegluegundowntocoolinasafemanner.Ensureithascooleddowncompletelybeforestorage.

9  Whennotinuseswitchthegluegunoff,removeplugfromthepowersupply,storethetoolinasafe,drychildproofarea.

NOTE:Thisapplianceisnotintendedforusebypersons(includingchildren)withreducedphysical,sensoryormentalcapabilitiesor

 lackofexperienceandknowledge,unlesstheyhavebeengivensupervisionorinstructionconcerningtheuseofthe  

 appliancebyapersonresponsiblefortheirsafety.Childrenshouldbesupervisedtoensurethattheydonotplaywiththeappliance.

1.2. ELECTRICAL SAFETY

9  Inspectthecableandconnectorforwearanddamagetoensureitemsaresafebeforeconnectingtothepowersupply.Ifwornor

8 DO NOTattempttoopen,disassemble,modifyorservicethebatterypack.

8 DO NOTcrush,puncture,shortexternalcontactsordisposeofinreorwater.

8 DO NOTexposetotemperaturesabove60°C(140°F).

9  Replaceonlywiththebatterypackdesignatedforthisproduct.

9  Recycleordisposeofusedbatteryasstipulatedbylocalregulation.

9  Iftheelectrolyteinthecellsgetsonyourskin,thoroughlywashwithsoapandwater.Ifitgetsinyoureyes,rinsethoroughlywithcool

 waterandseekimmediatemedicalattention.

Warning!

2. INTRODUCTION

Lightweightcordlessgluegunpoweredbya3.7V1.3AhLithium-ionbattery.FeaturesLEDlightindicatorstoshowwhenfullyheatedup.Ready

tousein20seconds.Operatingtimeof30minutesonafullcharge.SuppliedwithfourgluesticksandaUSBchargingcable.Suitablefor

Ø7.2mmgluesticks.

3. SPECIFICATION

4.4.  Thebatterycanbechargedatanytimewithoutreducing

 itsservicelife.Interuptingthechargingproceduredoes

 notdamagethebattery.

4.5.  Thebatteryisprotectedfromdeepdischarging.When

 thebatteryisdischagedthegluegunisswitchedoffby

 aprotectivecircuit.Theglueisnolongerheated.

4.6. BATTERY LED INDICATOR (RH)

Redashing:Batteryisbeingcharged

 Greensolid:Batteryisfullycharged

 Redashing(notpluggedintochargecable):Batteryis

5.1.  Saveenergy,onlyswitchonwhenbeingused.

5.2. SWITCH ON

 PressbuttonOn/Offtoturnon,untiltheHeatingLEDindicatorlightsgreen.DO NOTleaveunattendedwhilstgluegunisheatingup.

 Placeonaheatproofsurface.

5.3. HEATING LED INDICATORS(LH)

 Greenashing(forapproximately20seconds):glueisbeingheated

 Greensolid:gluegunreadytouse

5.4. SWITCH OFF

PressbuttonOn/OffuntilHeatingLEDindicatorturnsoff.

5.5. AUTOMATIC SWITCH OFF

5.8.2. Materialstobegluedaswellasthesurfaceonwhichtheworkistakingplacemustnotbeeasilyignitableorammable.

5.8.3. Checkthesuitabilityofmaterialstobegluedonatestworkpiece.

5.8.4. Ambienttemperatureofaworkpiecemustbebetween+5°Cand+50°C.

5.8.5. Materialssuchasmetals,whichcooloffthegluequickly,shouldbepreheatedwithahotairgun.

5.9. GLUING

5.9.1. Inserttheappropriategluestickintotheopeningintherearofthegluegun.

5.9.2. Switchonandallowtoheatup(see5.2above).Gluegunisreadyafterapproximately20seconds.

5.9.3. Pressthefeedtrigger,applyingmoderatepressure.

5.9.4. Applyglueontoonesideonly,pressthegluedsurfacestogether.Itisstillpossibletoadjustthelocationofthetwopiecesatthispoint.

5.9.5. Thegluedjointcanbesubjectedtoloadafteracooldownperiodofapproximatelytwominutes.

6.1.  Cleanwithadampcloth,DO NOTusesolvents.

AK2923|Issue:128/05/19

ENVIRONMENT PROTECTION

Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento

accordingtolocalregulations.

Note:Itisourpolicytocontinuallyimproveproductsandassuchwereservetherighttoalterdata,specificationsandcomponentpartswithoutprior

wasteauthorityforrecyclinginformation.

6.2.

6.3.

.

BATTERY REMOVAL

UndertheWasteBatteriesandAccumulatorsRegulations2009,JackSealeyLtdarerequiredtoinformpotentialpurchasersofproducts

SealeyLtd’sBatteriesProducerRegistrationNumber(BPRN)isBPRN00705.