Loading ...
WARNING
Improper installation, adjustment, alteration, service or mainte-
nance can causeDEATH, SERIOUS BODILY INJURY OR PROP-
ERTYDAMAGE. Refer to this manual for assistanceor consult
your local SearsService Center for further information.
WARNING
At the time of manufacture this water heater was equipped
with a temperature-pressure relief valve. For protection
against excessive pressures and temperatures in this water
heater, install temperature-pressure protective equipment
required by local codes, but not lessthan a combination tem-
perature-pressure rellef valve certified by nationally recog-
nized tesh_nglaboratory that maintains periodic inspection of
production Of listed equipment or materials, as meeting the
requirements for Relief Valves and Automatic Gas Shutoff
Devices for Hot Water Supply Systems,the latest edition ANSI
Z21.22. This valve must be marked with a maximum set pres-
sure not to exceed the marked hydrostatic working pressureof
the water heater (150 lbs./sq, in.). The relief valve must be
marked with a discharge capacity not less than the water
heater Btu input rate as shownon the model rating plate.
Install the temperature-pressure relief valve directly into the
firing of the water heater. Position the valve downward and
provide tubing so that any discharge will exit only within 6
inches above, or at any distancebelow the structural floor. Be
certain that no contact is made with any live electrical part.
The discharge opening must not be blocked or reduced in size
under any circumstances. Excessivelength, over 15 feet, or use
of more than two elbows can cause restriction and reduce the
dischargecapacity of the valve.
No valve or other obstruction is to be placed between the
relief valve and the tank;. Do not connect tubing directly to
discharge drain unlessa 6' air gap is provided. To prevent bod-
ily iniury, hazard to life, or damage property, the relief valve
must be allowed to discharge water in quantities should cir-
cumstancesdemand. If the discharge pipe is not connected to
a drain or other suitable means, the water flow may cause
property damage.
The Discharge Pipe:
-Must not be smaller in size than the outlet pipe size of the
valve, or have any reducing couplingsor other restriction.
-Must not be plugged or blocked.
-Must be of maten_allisted for hotwater distribution.
-Must be installed so asto allow complete drainage of both the
temperature-pressure relief valve, and the discharge pipe.
-Must terminate at an adequate drain.
-Must not have any valve between the relief valve and tank.
WARNING
A fire can start if combustible materials suchasclothing, clean-
ing materials, or flammable liquids are placed againstor next to
the water heater.
WARNING
WATER HEATERSEQUIPPED FOR ONE TYPE GAS ONLY: This
water, heater is equipped for one type gasonl)_.Check the rat-
mg plate near the gas control valve for the correct gas. DO
NOT USE THIS WATER HEATER WITH ANY GAS OTHER
THAN THE ONE SHOWN ON THE MODEL RATING PLATE.
Failure to use the correct gas can cause problems which can
result in DEATH, SERIOUS BODILY INJURY, OR PROPERTY
DAMAGE. tf you have any questionsor doubts consult your gas
supplier or local utility.
WARNING
INSTALLATION IN RESIDENTIAL AREASWHERE FLAMMABLE J
LIQUIDS (VAPORS) ARE LIKELYTO BE PRESENTOR STORED
(GARAGES; STORAGE, AND UTILITY AREAS, ETC):
Flammable liquids (such as gasoline, solvents, propane (LP) or
butane, etc.), all of which emit flammable vapors, may be
improperly stored or used in suchareas. The gas water heater
ilot hght or main burner can ignite such.vap°rs"The resulting
I_ashbackand fire can cause death or seriousburns to anyone
in the area, aswell as property damage.
If installation in suchareas is your only option, then the instal-
lation must be accomplished in a way that the pilot flame and
main burner flame are elevated from the floor at least 18 inch-
es. While this may reduce the changes of flammable vapors
from a floor spill being ignited, gasoline and other flammable
substancesshould never be store{]or usedin the same room or
area containing a gas water heater or other open flame or
spark producingappliance.
NOTE: Flammable vapors may be drawn by air currents from
other areas of the structure to the appliance.
WARNING
HOTTER WATER CAN SCALD: Water heaters are intended to
produce hot water. Water heated to a temperature which will
satisfy clothes washing, dish washing, and other sanitizing
needs can scald and permanently injure you upon contact.
Some people are more likely to be permanently injured by hot
water than others. These include the elderly, children, the
infirm, or physlcally/mentaIly handicapped, if anyone using
hot water in your home fits into one of these groups or if there
is a local code or state law requiring a certain temperature
water at the hot water tap, then you must take special precau-_
tions. In addition to usingthe lowest possible temperature set-'
ting that satisfiesyour hot water needs, some type of temper-
ing device, such as a mixing valve, should be used at the hot
water taps usedby these people or at the water heater. Mixing
valves are available at plumbing supply or hardware stores.
Follow manufacturers instructionsfor i*nstallationof the valves.
Before changing the factory setting on the thermostat, read the
"Temperature Regulation"section ;_nthis manual.
WARNING
BEFORE LIGHTING [PROPANE (L.P.) GAS WATER HEATERS]:
Propane (LP.) gasis heavier than air. Should there be a leak in
the system, the gas will settle near the ground. Basements,
craw/spaces, skirted areas under mobile homes (even when
ventilated), closetsand areas below ground level will serve as
pockets for the accumulation of this gas. Before attempting to
light or relight the water heater's pilot or turning on a nearby
electrical light switch, be absolutely sure there is no accumu-
lated gas in the area. Search for odor of gas by sniffing at
ground level in the vicinity of the appliance, tf odor is detect-
ed, follow steps indicated at "For Your Safety" on the cover
page of this manual then leave the premises.
WARNING
This water heater must not be installed directly on carpeting.
Carpeting must be protected by a metal or wood panel
beneath the appliance extending beyond the full width and
depth of the appliance by at least 3 inches (76.2mm) in any_
direction,, or if the appliance is installed in an alcove or closet,
the entire floor must be covered by the panel. Failure to heed
this warning may resultin afire hazard.
Loading ...
Loading ...
Loading ...