Loading ...
Loading ...
Loading ...
TROU LESHOOTING POUNTS
PROBLEM
Will not start
Hard to start
................ ,,,,,,,
Engine will not turn over
Engine clicks but will not
start
Loss of power
Excessive vibration
CAUSE
1 Out of fuel
2, Engine not "CHOKED" properly
3. Engine flooded
4,, Bad spark plug
5, Dirty air filter
6. Dirty fuel filter
7 Water in fuel
8, Loose or damaged wiring.
9.. Carburetor out of adjustment.
t0 Engine valves out of adjustment.
1 Dirty air filter
2 Bad spark plug
3 Weak or dead battery.
4. Dirty fuel filter_,
5, Stale or dirty fuel.
6, Loose or damaged wiring.
7 Carburetor out of adjustment.
8 Engine valves out of adjustmenL
1, Clutch/brake pedal not depressed
2 Attachment clutchis engaged,
3 Weaker dead battery
4, Blown fuse.
5. Corroded battery terminals
& Looseor damaged wiring,
7, Fault,} ignition switch.
8 Fault,/solenoid or starter
9 Faulty operator presence switch(es),
I, Weaker dead battery,
2,. Corroded battery terminals,
3 Looseor damaged wiring,
4 Faulty solenoid or starter.
1, Cutting too much grass!too fast.
2. Throttle in "CHOKE" position
CORRECTION
t. Fill fuel tank
2, See "TO START ENGINE" in Operation section,
3. Wait several minutes before attempting to start,
4, Replace spark plug,
5. Clean/replace air filter,
6 Replace fuel filter,
7 Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel filter,
8, Check all wiring,
9_ Contact an authorized service center/department,
10, Contact an authorized service center/department
I Cleanlreplace air filter
2, Replace spark plug
3 Recharge or replace battery_
4 Replace fuel filter
5, Drain fuel tank and refill with fresh gasoline.
& Checkall wiring
7, Contact an authorized service center/department
8 Contact an authorized service center/department
1_ Depress clutch/brake pedal
2, Disengage attachment clutch
3 Recharge or replace battery.
4 Replace fuse,
5 Clean battery terminals
6 Check all wiring
7. Check/replace ignition switch.
8, Check/replace solenoid or starter,
9, Contact an authorized service centeddepartment,
1 Recharge or replace battery,
2, Clean battery terminals,
3,, Check all wiring,
4, Check/replace solenoid or starter,
t, Set in "Higher Cut" position/reduce speed,
2. Adjust throttle control
3, Build-up of grass, leaves and trash under mower
4 Dirty air filter
5 Low oil ]eve!ldirty oil.,
6. Faulty spark plug
7,, Dirty fuel filter
8. Stale or dirty fuel
9 Water in fuel
t0, Spark plug wire loose,,
11. Dirty engine air screen/fins
t2 Dirty/clogged muffler
13, Loose or damaged wiring
14. Carburetor out of adjustment
15, Engine valves out of adjustment,
3, Clean underside of mower housing
4 Clean/replace air filter,,
5, Check oil levellchange oil
6 Clean and regap or change spark plug,,
7 Replace fuel filter,
8., Drain fuel tank and refill with fresh gasoline
9. Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel filter.,
10, Connect and tighten spark plug wire,
11 Clean engine air screen/f_ns.,
12 Clean/replace muffler,
t3, Check all wiring.
t Worn, bent or loose blade
2 Bent blade mandrel
3. Loose/damaged part(s)
t4,. Contact an authorized service center/department..
15, Contact an authorized service center/department
1 Replace blade Tighten blade bolt,
2, Replace blade mandrel.,
3 Tighten loose part(s) Replace damaged parts
Loading ...
Loading ...
Loading ...