Loading ...
Loading ...
Loading ...
7. TROUBLESHOOTING
7.1. If troubleshooting does not solve
the problem, contact your dealer or the
manufacturer directly. Use only original
parts approved by the manufacturer,
otherwise a hazard risk arises.
NO SPARK
Possible causes;
1. Carbon deposit between electrodes of the
spark plug.
2. Ignition coil defective flywheel magneto too
weak.
Possible corrective actions;
1. Clean the spark plug. Adjust the gap to 0.6 ~
0.7mm, Replace the spark plug.
2. Replace the Ignition coil or the flywheel.
WEAK SPARK
Possible causes;
1. Too much fuel in the combustion chamber,
poor fuel or water in tank.
2. Blocked fuel line
Possible corrective actions;
1. Remove spark plug and dry, replace fuel.
2. Clean the carburetor and clean the lines.
NORMAL FUEL SUPPLY BUT WEAK
COMPRESSION
Possible causes;
1. Worn piston rings, spark plug not tightened,
the cylinder head is not tightly wrong valve
clearance or ignition.
Possible corrective actions;
1. Replace or adjust.
NORMAL FUEL SUPPLY AND POOR SPARK
Possible causes;
1. Poor contact between spark plug cap and
spark plug.
Possible corrective actions;
1. Check or exchange.
MOTOR DOES NOT COME UPTO SPEED
Possible causes;
1. Choke is in "cold start" position, exhaust
system does not clog air supply, worn Movable
elements, spark weak, valve clearance to big,
sooty cylinder head.
Possible corrective actions;
1. Open choke, exhaust system ignition coil
exchange check or replace flywheel Adjust
spark plug.
POWER RUNS OUT
Possible causes;
1. Congested fuel lines to the carburetor.
Spark plug gap incorrect.
Possible corrective actions;
1. Unblock/Replace lines and carburetor. Reset
spark plug gap.
NOISY ENGINE
Possible causes;
1. Incorrect choke lever position, or damage to
crankshaft.
Possible corrective actions;
1. Check and correct choke lever position.
Check and/or replace crankshaft.
LEAKING CARBURETTOR
Possible causes;
1. Failure of the non-return valve on the fuel
tank lid. Worn carburetor gasket.
Possible corrective actions;
1. Replace the fuel cap. Replace the carburetor
seal.
Page 25
Ver 3 - September 2016
Loading ...
Loading ...
Loading ...