Loading ...
Loading ...
Loading ...
PROBLEM
Willnot start
Hard to start
Engine will not turn over
Engine clicks but will not
start
Less of power
Excessive vibration
i i...... : .................. ,...................... , ...........
TFIOIJEILISII OOTING POINTS
CAUSE CORRECTION
1. Out of fuel,
2, Engine net"CHOKED" propedy
3, Engine flooded
4, Bad spari{ plug
5. Dirty air filler
6, Dirty fuel filter
7. Water in fuel,,
& Loose or damaged widng.
9, Carburetor out of adjustment.
10, Engine valves out of adjustment,
1. Fill fuel tank.,
2, See "TO START ENGINE" in Operation secfion
3, Wait several minutes before attempting to start.
4. Replace spark plug.
5. Clean/replace alrfifler
6, Replace fuel filter.
7o Drain fuel lank and carburetor, refill tank wth fresh
gasoltne and replace fuel filler
8 Check all wiring.
g. Contact an aulhorized service canler/departmenL
10, Contact an aulborized service center/department
1, Dirty air ftten
2. Bad spark plug
3, Weak or dead battery
4. Dirty fuel filler,,
5. Stale or didy fuel
6. Loose or damaged wiring "
7. Carburetor out of adjustment,
8. Engine valves out of adjustment
1o Clutch/brake pedal not depressed.
2. Attachment clutch is engaged.
3, Weak or dead battery,
4. B_own fuse,
5. Corroded battery terminate.
6. Loose or damaged wiring,
7o Faulty Ignlfion switch
8o Faulty solenoid or starter,
9. Faulty operator presence switch(es),
1. Clean/replace air filter.
2. Replace spark plug
3. Recharg'e or replace battery.
4. Replace fuel niter.
5o Drain fuel tank and relll wIL.hfresh gasofne°
6. Check all wiring.
7o Contact an authorized service center/department
& Contact an authorized service center/department
1 Depress clutch/brake pedal
2. Disengage attachment clutch.
3- Recharge or replace battery,
4. Replace fuse,,
5. Clean battery terminals
6, Check allwiring
7, Checidreplaee _gnilien_switch,
8. Checfdraplace solenoid or starter
9, Contact an authorized service cenlerldapartment.
1,, Weak or dead battery
2. Corroded battery termlnaiso
& Loose or damaged Mring_
4, Faulty solenoid or starter.
1, Cutting too much grass/too fast,
2 Throttle in "CHOKE" position.
3. Build-up of grass, leaves and trash under mower.
4 Dirty air filter.
5. Low oil level/dirty oil
6o Faulty spark plug
7, Dirty fuel filter.
8. Stale or dirty fuel.
& Water in fuel
10. Spari_ plug wire loose,
11 Dirty engine air screen/fins.
t2 Dirtylclogged muffler,
13, Loose or damaged wiring.
14. Carburetor out of adjustment,
I5. Engine valves out of adjustment
to Worn, bent or loose blade.
2- Bent blade mandrel
3 Loose/damaged part(s).
1o Recharge or replace battery
2 Clean battery terminals
3 Check all wiring,
4, Checldraplace solenoid or starter,
1, Set in "Higher Cut" poslfiontreduce speed,
2, Adjust throttle control
& Clean underside of mower housing
4. Clean/replace air filter.
5, Check ofi laveVchange el,
6,, Clean and regap or change spari( plug.
7o Replace fuel filter.
8. Drain fuel tank and rafifi with fresh gasoline,
9. Drain fuel tank and carburetor, refill tank with fresh
gasotne and replace fuel filter,
10 Connect and tighten spark plug wire.
f 1,, Clean engine air screen/fins
12 Clean/replace muffler
13, Check all wiring,,
14,. Contact an authorized service centerldepartment.,
15. Contact an authorized service centar/dspartmento
1 Replace blade, Tighten blade bolt.
2. Replace blade mandrel.
& Tighten loose part{s)o Replace damaged parts.
27
Loading ...
Loading ...
Loading ...