Loading ...
Loading ...
Loading ...
iiil.llll,llliii illl.i illll j .,lll,,lll,l,,ll,i, ii IlL i i i_
TROUBLESHOOTING POmNTS
Hll.J ................................... ,i,iui.............................
PROBLEM
Will not start
Hard to start
Engine will not turn over
Engine clicks but will not
start
Loss of power
Excessive vibration
CAUSE
1 Out of fuel
2.. Engine not "CHOKED" properly.
3, Engine flooded
4 Bad spark plug
5. Dirty air fitter
6, Dirty fuel filter.
7.. Water in fuel.
8. Loose or damaged wiring,
9, Carburetor out of adjustment
10,, Engine valves out of adjustment
1. Dirty air filter,,
2, Bad spark plug
3., Weak or dead battery,
4. Dirty fuel filter.
5- Stale or dirty fiJel,
6. Loose or damaged widng..
7o Carburetor out of adjustment
8. Engine valves out of adjustment.,
i,, Clutch/brake pedal not depressed
2, Attachment dutch is engaged.
3 Weak or dead battery
4. Blown fuse,,
5 Corroded batter,] terminals_
6, Loose or damaged wiring.
7, Faulty ignition switch
8 Faulty solenoid or starter.
9. Fautty operator presence switch(as)
1 Weak or dead battery,
2 Corroded battery terminals.
3., Loose or damaged widng,
4. Faulty solenoid or starter,
t., Cutting too much grass/too fast,
2. Throttle in "CHOKE" position.
3 Buird_up of grass, leaves and trash under mower
4, Dirty air rifler..
5 Low oif level!dirty oil.
6. Faulty spark plug
7. Dirty fuel fitter,
8. Stale or dirty fuel,,
9 Water in fuel
10. Spark ptug wtreloose,
11 Dirty engine air screentfine
12, Dtrtylclogged muffler,
13., Loose or damaged wiring°
14 Carburetor out of adjustment,,
15. Engine valves out of adjustmen'!_
1, Worn, bent or toose blade,
2, Bent blade mandrel.
3, Looeeldamaged part(s),
CORRECTION
1,, Fill fuel tank°
2o See "TO START ENGINE" in Operation section,
3. Wait several minutes before attempting to start
4_ ReplacB sparkptug,
5 Clean/replace air filter,
6, Replace fuel filter.
7. Drain fue_ tank and carburetor, refill tank with fresh
gasortne and replace fuel _tter,
8 Check alf wtdng,
9. Contact an authorized service center/department,
10. Contact an authorized service center/department,
1 Clean/replace air filter.,
2. Replace spark plug,
3. Recharge or replace battery
4, Replace fuel filter
5 Drain fuet tank and refill with fresh gasoline,,
6 Check all wtdng,
7 Contact an authorized service center/department,
8, Contact an authorized service centerldepartment.
1 Depress c]utchJbrake pedal
2. Disengage attachment clutch,
3., Recharge or replace battery.
4. Replace fuse,,
5 Clean battery terminals
6. Check all wldng,
7, ChecWreptace Ignition switch.
8. Check/replace soteno]d or starter.
9 Contact an authodzed service center/departmenL
1.. Recharge or replace battery
2, Clean battery terminals
3. Check all wiring
4 Check/replace solenoid or starter,
1, Set in "Higher Cut" position/reduce speed,
2. Adjust throttle control
3 Clean underside of mower houelng_
4, Clean/replace air filter
5, Check oil leve!fchange ell
6. Clean and regap or change spark plug.,
7. Replace fuel fitters,
8. Drain fuel tank and refill with fresh gasoline_
9, Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel filter.
t 0. Connect and tighten spark plug wire
I1. Clean engine air screeniflns_
12. Clean/replace muffler
13_ Check all wtdng
14 Contact an authorized service centerldepartmenL
15 Contact an authodzed service center/department,
1_ Replace blade, Tighten blade bolt
2 Replace blade mandrel.
3 Tighten loose part(s), Replace damaged parts.,
27
Loading ...
Loading ...
Loading ...