Loading ...
Loading ...
Loading ...
-15-
CAUTION:
Replace glass only with 5mm high temperature ceramic glass of the proper size. Do not use tempered glass or
double thickness window glass.
ATTENTION:
This wood heater needs periodic inspection and repair for proper operation. It is against federal regulations to
operate this wood heater in a manner inconsistent with operating instructions in this manual.
REMOVING THE INSERT FOR PURPOSE OF INSPECTION
If for any reason you must remove the insert for inspection of the appliance or replace, follow these rules.
1. Ensure appliance is not in operation and is thoroughly cooled.
2. Remove the surround by removing the springs retaining it to the appliance.
3. Disconnect the ue gas pipe from the appliance.
4. Slide appliance out to perform inspection.
GLASS REPLACEMENT
1. Ensure appliance is not in operation and is thoroughly cooled.
2. Remove screw and glass clip. (See parts list and diagram.)
3. Lift glass out from glass clip.
4. Remove old gasket and clean glass.
5. Replace new gasket starting at the bottom of glass working along edges, being sure to center gasket channel
on glass.
6. Trim to length and butt ends together.
7. Replace glass into door, being sure not to overtighten screw and clip.
After extensive use, the gasket material which provides glass and door seal may lose it’s resiliency and will need
to be replaced. Inspect glass and door gaskets periodically to ensure proper seal; if gaskets become frayed or
worn, replace immediately. This unit’s door uses a 1” diameter rope gasket.
DOOR GASKET REPLACEMENT
1. Ensure appliance is not in operation and is thoroughly cooled.
2. Remove old door gasket and clean channel.
3. Using an approved, high temperature gasket cement, apply a thin coat in bottom of channel.
4. Starting at hinge side of door, work gasket into channel around door unit, end butt and trim to length.
5. Close door and allow three to four hours for cement to set before ring appliance.
WARNING:
NEVER OPERATE THE STOVE WITHOUT A GASKET OR WITH A BROKEN ONE. DAMAGE TO THE STOVE OR EVEN
HOUSE FIRE MAY RESULT.
Loading ...
Loading ...
Loading ...