Milwaukee 49-08-5385 Max-Lok Replacement Grease User Manual

Page1of7

58‐97‐5385

Max‐LocGrease

   02A

SECTION1:PRODUCTANDCOMPANYIDENTIFICATION



ProductName: Max‐LocConnectionGrease DrawingNumber: 58‐97‐5385 

ProductModels: 49‐08‐5385 IssueDate: March2015 

 SupersedesDate: March2012 



MilwaukeeElectricToolCorporation CompanyPhoneNumber: 262‐781‐3600or

13135WestLisbonRoad 1‐800‐729‐3878

Brookfield,Wisconsin53005 EmergencyContactNumber:

1‐800‐424‐9300

www.milwaukeetool.com Chemtrec:UnitedStatesonly



Recommendedintendedpurposetobeusedasalubricant



SECTION2:HAZARDSIDENTIFICATION



Health Environmental Physical

EyeIrritation:Noclassifiedhazards AcuteToxicity: Noclassifiedhazards Flammableliquid:Noclassifiedhazards

SkinIrritation:Noclassifiedhazards ChronicToxicity: Noclassifiedhazards

AcuteToxicity,Oral:Noclassified

hazards



AcuteToxicity,Inhalation:Noclassified

hazards



GHSLabel

Noapplicablelabeling



HazardStatements PrecautionaryStatements

Maycauseeyeirritation IFINEYES:rinsecautiouslywithwaterforseveralminutes.

Removecontactlenses,ifpresentandeasytodo.

 IFeyeirritationpersists:getmedicalattention/advice.

Maycausemildskinirritation Washskin/handsthoroughlyafterhandling.

 IFskinirritationoccurs:getmedicalattention/advice.

Maybeharmfulifswallowed IFSWALLOWED:callaPOISONCENTERordoctor/physicianif

youfeelunwell.

Maybeharmfulifinhaled IFINHALED:callaPOISONCENTERordoctor/physicianifyou

feelunwell.

 Usepersonalprotectiveequipmentasrequired.



ClassifiedHazards

ThismaterialisnothazardousunderthecriteriaoftheFederalOSHAHazardCommunicationStandard29CFR1910.1200.

ThisSDScontainsvaluableinformationforthesafehandlingandproperuseofthisproduct.SavethisSDSforfuture

reference.



OtherHazards

 Noneknown

SafetyDataSheet

Maybeusedtocomplywith

OSHA’sHazardCommunicationStandard29CFR1910.1200.

Thisstandardmustbeconsultedforspecificrequirements.

Page2of7

58‐97‐5385

Max‐LocGrease

   02A

SECTION3:COMPOSITION/INFORMATIONONINGREDIENTS



Componentslistedinthissectionmaycontributetothepotentialhazardsassociatedwithexposuretotheconcentrate.The

productmaycontainadditionalnon‐hazardousortrade‐secretcomponents.

Chemicalcharacterization

 Lubricatinggrease:thickeningagent,additivesandsolidlubricantsinhighly‐refinedmineraloil



ChemicalName CAS# Concentration

Mineraloil Proprietary <5

Non‐hazardousmaterials Proprietary Balance

Note:ThisproducthasbeenevaluatedanddoesnotrequireanyhazardwarninglabelundertheOSHAHazardCommunication

Standard.



Allconcentrationsarepercentbyweightunlessingredientisagas.Gasconcentrationsareinpercentbyvolume



CarcinogenicComponents:Thisproductcontainsnocarcinogens.



SECTION4:FIRSTAIDMEASURES



EYECONTACT:

 Holdeyelidsopenandflushwithasteady,gentlestreamofwaterforatleast15minutes.Ifsymptomspersist,contacta

physician.



SKINCONTACT:

 Removeproductfromtheskinbywashingwithamildsoapandwater.Contaminatedclothingshouldberemovedtoprevent

prolongedexposure.

Ifsymptomsofexposurepersist,contactphysician.Ifproductisinjectedintoorundertheskin,seek

treatmentimmediately.(seeNotetoPhysician)



INHALATION:

 Ifsignsorsymptomsofoverexposureoccur,removethepersontofreshair.Ifsymptomspersist,seekmedicalattention.



INGESTION:

 Firstaidisnotnormally

required;however,ifsymptomsofingestionpersist,seekmedicalattention.Donotinducevomiting.



NOTETOPHYSICIAN:

Whenusinghigh‐pressureequipment,injectionofproductundertheskincanoccur.Inthiscase,thecasualtyshouldbesent

immediatelytohospital.Donotwaitforsymptomstodevelop.High‐pressure

hydrocarboninjectioninjuriesmayproduce

substantialnecrosisofunderlyingtissuedespiteaninnocuousappearingexternalwound.Theseinjuriesoftenrequireextensive

emergencysurgicaldebridementandallinjuriesshouldbeevaluatedbyaspecialistinordertoassesstheextentofinjury.Early

surgicaltreatmentwithinthefirstfewhoursmay

significantlyreducetheultimateextentofinjury.



SECTION5:FIREFIGHTINGMEASURES

NFPA704HazardClass

 Nodataavailable

HMIS



Page3of7

58‐97‐5385

Max‐LocGrease

   02A

EXTINGUISHINGMEDIA:

 InaccordancewithNFPAguidance,drychemical,foam,orCO2fireextinguishersareallacceptable.Notethatwhilewaterfog

extinguishersarealsoacceptable,DONOTapplyadirectstreamofwaterontoburningproductbecauseitmaycausespreading

andincreasefireintensity.



UNUSUALFIRE&EXPLOSION

HAZARDS:

 Nofurtherdataknown.



FIRE‐FIGHTINGPROCEDURESANDEQUIPMENT:

Emergencyrespondersinthedangerareashouldwearbunkergearandself‐containedbreathingapparatusforfiresbeyondthe

incipientstage.SeeSection8oftheMSDSforotherPPEtobewornasconditionswarrant.



SeeSection9

forFlammablePropertiesincludingFlashPointandFlammable(explosive)limits.



SECTION6:ACCIDENTALRELEASEMEASURES



Clean‐UpMeasures:

 Important:Aswithanyspillorlead,beforerespondingensurethatyouarefamiliarwiththepotentialhazardsand

recommendationsoftheMSDS.Appropriatepersonalprotectiveequipmentmustbeworn.SeeSection8ofthisMSDSforPPE

recommendations.



 Ifpossible,safelycontainthespillwith

dikesorotherspillresponseequipmentappropriateforpetroleumororganicmaterial

releases.Takemeasurestopreventspreadingofproduct.Notethatwhileproductwilligniteitwillnotreadilyburn.However,

asaprecautioneliminateignitionsources.Preventfromenteringsewersorwaterways.Largevolumesmaybetransferredto

anappropriatecontainerforproperdisposal.Smallvolumesorresiduesmaybesoakedupwithabsorbents.Spillresponse

materialsshouldbecollectedforproperdisposal.



SECTION7:HANDLINGANDSTORAGE



HANDLING:

 Aswithanyindustrialchemical,handletheproductinamannerthatminimizesexposuretopracticablelevels.Priortohandling,

consultSection8ofthisMSDStoevaluatepersonalprotectiveequipmentneeds.Opencontainersslowlytorelieveany

pressure.Followallotherstandardindustrialhygienepractices.



 Emptycontainers

maycontainproductresidue.Allsafetyprecautionstakenwhenhandlingthisproductshouldalsobetaken

whenhandlingemptydrumsandcontainers.Keepcontainersclosedwhennotinuse.



 Productresidueinemptycontainersiscombustiblebutwillnotreadilyburn.NOTEhowever,thatexcessiveheatingorcutting

of

emptycontainersmaycreateanignitionssourcesufficienttostartafireandinextremecases,causeanexplosion.



STORAGE:

Protectproductqualitybystoringindoorsandawayfromextremetemperatures.Closeallcontainerswhennotinuse.



SPECIALCOMMENTS:

Nofurtherdataknown.



Page4of7

58‐97‐5385

Max‐LocGrease

   02A

SECTION8:EXPOSURECONTROLS/PERSONALPROTECTION



SelectionofpersonalprotectiveequipmentshouldbebasedupontheanticipatedexposureandmadeinaccordancewithOSHA’s

PersonalProtectiveEquipmentStandardfoundin29CFR1910SubpartI.ThefollowinginformationmaybeusedtoassistinPPE

selection.



ChemicalName

OSHA

PEL

ACGIH

TLV

CaliforniaProp65

Reg.Y/N



IARC/NTP

Y/N

MineralOil TWA

5mg/m

*

TWA

5mg/m

*

N N

Note:ThisproducthasbeenevaluatedanddoesnotrequireanyhazardwarninglabelundertheOSHAHazardCommunication

Standard.



*Asoilmist,ifgenerating



EYEPROTECTION

Weareyeprotectionappropriatetopreventeyeexposure.Wheresplashingisnotlikely,chemicalsafetyglasseswithside

shieldsarerecommended.Wheresplashingmayoccur,chemicalgogglesorfullfaceshieldisrecommended.



SKINPROTECTION:

Glovesarenotnormallyneededduringnormalconditionsofuse.Ifhealth

effectsareexperienced,oilorchemicalresistant

glovessuchasbutylornitrilearerecommended.



Wheresplashingorsoakingislikely,wearoilorchemicalresistantclothingtopreventexposure.



RESPIRATORYPROTECTION:

Arespiratormaybeworntoreduceexposuretovapors,dust,ormist.SelectaNIOSH/MSHAapprovedrespirator

appropriate

forthetypeandphysicalcharacteroftheairbornematerial.Aself‐containedbreathingapparatusisrecommendedinall

situationswhereairbornecontaminantconcentrationhasnotbeenconfirmedtobebelowsafelevels.Respiratoruseshould

complywiththeOSHARespiratorProtectionStandardfoundinCFR1910.134.



ENGINEERINGCONTROLS:



 Normalgeneralventilationisexpectedtobeadequate.Itisrecommendedthatventilationbedesignedinallinstancesto

maintainairborneconcentrationsatlowestpracticablelevels.Ventilationshouldataminimum,preventairborne

concentrationsfromexceedinganyexposurelimitslistedinSection2ofthisMSDS.



 Theusermay

wishtoreferto29CFR1910.1000(d)(2)andtheACGIH“ThresholdLimitValuesforChemicalSubstancesand

PhysicalAgentsBiologicalExposureIndices”(AppendixC)forthedeterminationofexposurelimitsofmixtures.Anindustrial

hygienistorsimilarprofessionalmaybeconsultedtoconfirmthatthecalculatedexposurelimits

apply.



SECTION9:PHYSICALANDCHEMICALPROPERTIES

Datarepresenttypicalvaluesandarenotintendedtobespecifications.NA=NotApplicable;ND=NotDetermined



 Physicalstate:.................................Pasty Flammability(solid,gas):.............................ND

 Colour:............................................Copper UpperExplosiveLimits(vol%inair):..........NA 

 Odor:..............................................LikeMineralOil LowerExplosiveLimits(vol%inair):...........

NA

 OdorThreshold:.............................ND Vaporpressure:............................................ND

 pH:.................................................ND Vapordensity:..............................................ND

 Melting/FreezingPoint:.................ND Relativedensity:...........................................ca.0,9g/cm3,20

C

 VOCContent:..................................ND Solubility:......................................................MoreOrLessInsoluble

Page5of7

58‐97‐5385

Max‐LocGrease

   02A

 BoilingPoint:..................................ND PartitionCoefficient:....................................ND

 FlashPoint:.....................................NA Auto‐ignitionTemperature:.........................ND

 EvaporationRate:...........................ND DecompositionTemperature:......................ND

 SpecificGravity:............................ND Viscosity:.......................................................ND



 

SECTION10:STABILITYANDREACTIVITY



INCOMPATIBLEMATERIALS:

Thisproductisincompatiblewithstrongoxidizingagents.



DECOMPOSITIONPRODUCTSMAYINCLUDE:

 Thermaldecompositionproductsaredependentoncombustionconditions.Acomplexmixtureofairbornesolid,liquid,

particulatesandgassesmayevolvewhenthematerialburns.



CONDITIONSTOAVOID:

Avoidcontactwithincompatiblematerialsandexposure

toextremetemperatures.



POLYMERIZATION:

Thisproductisnotexpectedtopolymerize.



CHEMICALSTABILITY:

Thisproductisstable.



REACTIVITY:

 Stableundernormalambientandanticipatedconditionsofuse.



SECTION11:TOXICOLOGYINFORMATION



LIKELYROUTESOFEXPOSURE: Inhalation,EyeandSkincontact



ACUTESYMPTOMSANDEFFECTS:

Inhalation: Nofurthertoxicologicaldataknown

Eyecontact: Nofurthertoxicologicaldataknown

Skincontact: Nofurthertoxicologicaldataknown

Ingestion: Nofurthertoxicologicaldataknown

 

OTHER:

Nofurtherdataknown.



SECTION12:ECOLOGICALINFORMATION



ECOTOXICOLOGICALINFORMATION:

Thisproducthasnotbeenevaluatedforecotoxicity.Aswithanyindustrialchemical,exposuretotheenvironmentshouldbe

preventedandminimizedwhereverpossible.



TOXICITY:

 Nodataavailable



Page6of7

58‐97‐5385

Max‐LocGrease

   02A

PERSISTENCEANDDEGRADABILITY(BIOPERSISTENCY&BIODEGRADABILITY):

 Nodataavailable



POTENTIALOFBIOACCUMULATION:

 Nodataavailable



MOBILITYINSOIL:

 Nodataavailable



OTHERADVERSEEFFECTS:

 Nodataavailable



SECTION13:DISPOSALCONSIDERATIONS



WASTEDISPOSAL:

Ensurethatcollection,transport,treatment,anddisposalofwasteproduct,containersandrinsatecomplieswithallapplicable

lawsandregulations.Notethatuse,mixture,processing,orcontaminationoftheproductmaycausethematerialtobe

classifiedasahazardouswaste.Itistheresponsibilityoftheproduct

userorownertodetermineatthetimeofdisposal,

whethertheproductisregulatedasahazardouswaste.



SECTION14:TRANSPORTINFORMATION



DOTHAZARDOUSMATERIALINFORMATION:

NototherwiseDOTregulated.



SECTION15:REGULATORYINFORMATION



FEDERALREGULATIONS:

 SARA313:

ThisproductcontainsNONEofthesubstancessubjecttothereportingrequirementsofSection313ofTitleIIIofthe

SuperfundAmendmentsandReauthorizationActof1986and40CFRPart372.



 CleanWaterAct/OilPollutionAct:

 Thisproductcontainsmineraloil

andissubjecttoregulationbySection311oftheCleanWaterActandtheOilPollution

Act.ReleasesoftheproductintoorleadingtosurfacewatersmustbereportedtotheNationalResponseCenterat1‐800‐

424‐8802.



 CERCLAReportableQuantity:

 Anycomponentslistedbelowhave

beenassignedareportablequantity(RQ)bytheFederalEPA.Releasesoftheproduct

intotheenvironmentthatexceedtheRQforaparticularcomponentmustbereportedtotheNationalResponseCenterat

1‐800‐424‐8802.

 

ToxicSubstanceControlAct:

Thecomponentsofthisproductarelisted

ontheTSCAInventory.



 OzoneDepletingSubstances:

ThisproductcontainsnoozonedepletingsubstancesasdefinedbytheCleanAirAct.



HazardousAirPollutants:

 AnycomponentslistedbelowaredefinedbytheFederalEPAashazardousairpollutants.



Page7of7

58‐97‐5385

Max‐LocGrease

   02A

STATEREGULATIONS:

 Thisproductcontainsmineraloil,andasused,mayberegulatedbythestateusedoilregulations.Checkwiththeappropriate

stateagencytodeterminewhethersucharegulationexists.



 Nofurtherdataknown.



SECTION16:OTHERINFORMATION



ABBREVIATIONS:

 TSCA.....................ToxicSubstanceControlAct

 ICAO.....................InternationalCivilAviationOrganization

 IMDG......................InternationalMaritimeDangerous

 OSHA....................OccupationalSafetyandHealth

 IARC/NTP...............InternationalAgencyforResearchonCancer/NationalToxicologyProgram

 SARA.....................SuperfundAmendmentsandReauthorizationActof1986

 ACGIH...................AmericanConference

ofGovernmentalIndustrialHygienists

 NIOSH/MSHA........NationalInstituteforOccupationalSafetyHealth/

 MineSafetyandHealthAdministration

 WHMIS...................WorkplaceHazardousMaterialsInformationSystem



Preparedby: MilwaukeeElectricToolCorporation



Theinformationandrecommendationssetfortharemadeingoodfaithandbelievedtobeaccurateas

ofthedateofpreparation.

MILWAUKEEELECTRICTOOLCORPORATIONmakesnowarranty,expressedorimplied,regardingtheaccuracyofthisdataorthe

resultstobeobtainedfromtheusethereto.Allrisksassociatedwithproductuseareassumedbytheuser.



Milwaukee 49-08-5385 Max-Lok Replacement Grease

Product's Documents

Manual 58-97-5385

Specifications

Milwaukee 49-08-5385 Questions and Answers