Loading ...
Loading ...
Loading ...
TROUBLESHOOTING POmNTS
i ....................................
PROBLEM CAUSE CORRECTION
Wlll not start
Hard to start
ii iin i iqnll
Engine will not turn over
Engine clicks but wilt not
start
Loss of power
Excessive vibration
1 Out of fuel
2 Engine not "CHOKED" properly
3 Engine flooded
4, Bad spark plug
5 Dirty air rifler
6 Dirty fuel filter
7 Water in fuel,
8. Loose or damaged wiring.
9_ Carburetor out of adjustment
10 Engine vafves out of adjustment
t Dirty air fitter
2 Bad spark plug
3 Weaker dead battery.
4 Didy fuel filler
5, Stale or dirty fuel.
6, Loose or damaged wiring
7 Carburetor out of adjustment
8,
JJ
Engine valves out of adjustment
1 Clutch/brake pedal not depressed
2 Attachment clutch is engaged.
3 Weak or dead battery,
4 Brown fuse,
5 Corroded battery terminals
6_ Loose or damaged wiring
7 Faulty ignition swttch,
8 Faulty solenoid or starter
9, Faulty operator presence switch(as)
1 Weak or dead battery
2 Corroded battery terminals
3 Loose or damaged wiring
4 Faulty solenoid or starter
1 Cutting too much grassltoo fast.
2 Throttle in "CHOKE" position.
3 Build-up of grass, teaves and trash under mower,
4 Dirty air filter,
5, Low oil levelldirty oli.
6 Faulty spark plug,
7 Dirty fuel filter,
8, Stale ordirty fuel,
9 Water in fuel
10 Spark plug wire loose
t 1 Dirty engine air screen/fins
12 Dirty/clogged muffler
13 Loose or damaged wiring
14 Carburetor out of adjustment,
15 Engine valves out of adjustment
1 Worn, bent or foose blade.
2 Bent blade mandrel,
3 Loose;damaged part(s)
1 Fill fuel tank
2, See "TO START ENGINE" in Operation section.
3 Wait several minutes before attempting to start
4. Replace spark plug.
5. Clean;replace air filter
6. Replace fuel filter,
7 Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel filter
8 Check all wiring,
9_ Contact an aulhorized service center/department,
1 O, Contact an aulhorized service center/department.
1- Cieanfreplace air fitter,
2. Replace spark plug.
3, Recharge or replace battery
4, Replace fuel filter
5. Drain fuel tank and refill with fresh gasoline.
6. Check all wiring
7- Contact an authorized service center/department
8 Contact an authorized service center;department.
1, Depress clutch/brake pedal
2. Disengage attachment clutch.
3- Recharge or replace battery,
4. Replace fuse
5 Ctean battery terminals
6. Check all wiring
7. Check/replace ignifion switch
8. Check/replace solenoid or starter
9. Contact an authorized service center/department
1. Recharge or replace battery
2. Clean battery terminals
3. Check all wiring
4. Check/replace solenoid or starter.
1, Set in "Higher Cut" position#educe spee&
2_ Adjust throttle control,
3 Clean underside of mower housing
4- Cfeantreplace air filter
5 Check oil level/change oil,
6, Clean and regap or change spark piug
7,, RepIace rue1 filter,
8. Drain fuel tank and refill with fresh gasoline,
9. Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel filter.
t0. Connect and tighten spark plug wire
11 Clean engine air screen/tins
12 Clean/replace muffler.
13. Check all wiring
14, Contact an authorized service center/department
t5 Contact an authorized service centefldepartment,
1 Replace blade Tighten blade bolt
2 Replace blade mandrel
3 Tightentoose part(s) Replace damaged parts
Loading ...
Loading ...
Loading ...