VIAIR 40047 User Manual

Loading ...

400P-RV AUTOMATIC PORTABLE COMPRESSOR

OPERATING INSTRUCTIONS:

Pleasereadandfollowtheoperatinginstructionscarefullytoassurethatyouwillenjoythe

convenienceandbestuseoutofyouraircompressor.

1.AlwaysoperatethecompressorATORBELOWTHEMAXIMUMPRESSURERATINGofthe

 compressor.RefertoSpecicationssectionofthismanual.

2.AlwaysOBSERVETHEMAXIMUMDUTYCYCLEoftheaircompressor.RefertoSpecications

 sectionofthismanualfordetails.Operationsexceedingmaximumpressureratingsandorduty

 cyclewillresultindamagetoaircompressor.

3.YouraircompressorisequippedwithanAUTOMATICTHERMALOVERLOADPROTECTOR.

 Thisfeatureisdesignedtoprotecttheaircompressorfromover-heatingandcausingpermanent

 damagetoyouraircompressor.Thethermaloverloadprotectorwillautomaticallycutopower

 toaircompressorshouldinternaloperatingtemperatureoftheaircompressorriseabovesafe

 levelsduringexcessiveuse.

4.Shouldyourcompressorshutosuddenlyafterextendeduse,donotattempttorestartair

 compressor.TurnON/OFFswitchofaircompressortotheOFFposition.Theautomaticthermal

 overloadprotectorwillautomaticallyresetwheninternaltemperatureoftheaircompressordrops

 belowsafelevel.Afterallowingaircompressortocooloforabout30minutes,youcansafely

 resumeuseoftheaircompressorbyturningontheaircompressor.

5.Foryourconvenience,andtoprotecttheaircompressorfromover-pressureoperationthatcan

 causepermanentdamagetotheunit-thiscompressorisequippedwithbuilt-inpressureswitch

 withafactorysetcut-onpressureof130PSI(±5%)andafactorysetcut-opressureof

 155PSI(±5%).Duringinationoftirepressuresbetween130PSIto155PSI,ifyoustopination,

 thecompressormaynotrestart.Thisiscompletelynormal,sinceinlinepressureisgreaterthan

 cut-onpressureofthepressureswitchandlessthancut-opressureofthepressureswitch.

 Torestartcompressor,deatetirepressuretobelow130PSI,reconnecttirechucktotirevalve

 stemandresumetireination.

6.Pleasenotethatyoumayexperienceaslightdelayofthecompressor’smotorstartingwhenthe

 ON/OFFswitchisturnedonwhilecompressorispressurized(whenthereispressureintheline

 thatthecompressorisconnectedto).Thisisanormaldelayedreaction,notaCompressor

 ON/OFFswitchmalfunction.

7.Itisstronglyrecommendedthatyoukeepthevehicle’senginerunningwhileusingtheair

 compressortopreventdischargeofyourvehicle’sbattery.

8.ONLYOPERATETHEAIRCOMPRESSORINWELLVENTILATEDAREAS.

 Compressorperformanceisenhancedwhenoperatingcompressorwithvehicleenginerunning.

IMPORTANT:Enginemustberunningwhileusingthiscompressor.

Beforeattachingaircompressorpowerclampstoyourvehicle’sbatteryterminals,checktomake

surethattheON\/OFFswitchofyourcompressorisintheOFFposition.AttachthePositive(+)

batteryclamp(Red)tothePositiveterminalofthebatteryandtheNegative(-)batteryclamp(Black)

totheNegativeterminalofthebattery.Alwayskeepyourvehicle’senginerunningwhileoperating

compressortoavoiddrainingyourvehicle’sbattery.

CAUTION:YourPortableAirCompressorisMoistureandDustResistant,butNOTWATERORDUST

PROOF.Neverplacecompressorinsoftsandwhilerunningthecompressor.Vibrationfromthe

compressorwillcausethecompressortosettleintosoftsand,resultingincompressordrawingin

foreignparticles.Neverexposecompressortowaterwhilerunningthecompressor.

USER MANUAL

Loading ...

VIAIR 40047 400P RV Automatic Portable Compressor Kit, Tire Pump, Truck/SUV Tire Inflator, Silver,

User Manual - Page 3