Loading ...
Loading ...
Loading ...
TROUBLESHOOTING CHART:
See appropriate section in manual unless directed to Sears service center
PROBLEM CAUSE CORRECTION
Poor cut - uneven
cutting
Mower blades will
not rotate
Poor grass
discharge
1 Worn, bent or looseblade.
2 Mower deck not level.
3 Buildupof grass,leaves, and
trashundermower.
4 Bent blademandrel.
5 Cloggedmowerdeck vent from
build,upof grass, leaves, and
trasharoundmandrels.
1 Obstructionin clutchmechanism.
2 Worn/damagedmower drive belt.
i3 Frozenidler pu ley.
4 Frozenblade mandrel.
1 Enginespeed too slow.
J2 Travelspeed toofast.
3 Wet grass.
4 Mower deck not level.
1 Replace blade.Tightenblade bolt.
2 Level mowerdeck.
3 Clean undersideof mower
housing.
4 =Contact a Sears orother
qualifiedservicecenter.
5 Clean aroundmandrelsto
openvent holes.
1 Remove obstruction.
2 Replace mowerdrivebelt.
3 Replace idlerpulley.
4 Contacta Sears orother
qualifiedservicecenter.
1 Place throttlecontrol in "FAST"
position.
2 Shiftto slowerspeed.
3 Allow grass to drybefore mowing.
4 Levelmower deck.
5 Low/uneventire air pressure.
6 Worn, bent or looseblade.
5 Check tiresfor properPSI.
6 Replace/sharpenblade. Tighten
bladebolt.
7 Buildupof grass, leaves and
trashundermower.
8 Mowerdrive beltworn.
9 Bladesimproperlyinstalled.
10 Improperbladesused.
7 Clean underside of mower
housing.
8 Replace mower drive belt.
9 Reinstall blades sharp edge down.
10 Replace with blades listed in
this manual.
Headlight(s) not
working
(if so equipped)
Battery will not
charge
11 Clogged mower deck vent holes
from buildup of grass, leaves, and
trasharound mandre s
1 Lightswitchis "OFF".
2 Bulb(s)or lamp(s) burnedout.
3 Faultylightswitch.
4 Looseor damagedwiring.
5 Blownfuse.
1 Bad batterycell(s).
2 Poorcable connections.
11 Clean around mandrels to
open vent holes.
1 Turnlightswitch"ON".
2 Replace bulb(s) or lamp(s).
3 Check/replacelightswitch.
4 Check wiringand connections.
5 Replacefuse.
1 Replace battery.
2 Check/clean all connections.
3 Faultyregulator (if so equipped). 3 Replace regulator.
4 Faultyalternator. 4 Replace alternator.
30
Loading ...
Loading ...
Loading ...