Loading ...
Loading ...
Loading ...
TROUBLESHOOTING POINTS
PROBLEM
Will not start
Hard to start
Engine will not turn over
Engine clicks but will not
start
Loss of power
Excessive vibration
CAUSE
1. Out of fuel.
2. Engine not "CHOKED" propedy.
3. Engine flooded.
4. Bad spark plug.
5. Dirty air filter.
6. D!rty fuel tilter.
7. Water in fuel
8. Loose or damaged widng.
9. Carburetor outof adjustment.
10, Engine valves out of adjustment.
1. Dirty air filter.
2. Bad spark plug.
3. Weak or dead battery.
4. Dirty fuel filter.
5. State or dirty fuel.
6. Loose or damaged wiring.
7. Carburetor outof adjustment.
8. Engine valves out of adjustment.
1. Clutch!brake pedal not depressed.
2, Attachment dutch is engaged.
3. Weak or dead battery.
4. Blown fuse.
5. Corroded battery terminals.
6. Loose or damaged wiring.
7. Faulty ignitionswitch.
8. Faulty solenoid or starter.
9. Faulty operator presence swffch(es).
1. Weak or dead battery.
2. Corroded battery terminals.
3, Loose or damaged wiring.
4. Faulty solenoid or starter.
1. Cuing too much grass/too fast.
2. Throttle in "CHOKE" position.
3. Build-up of grass, leaves and trash under mower.
4. Dirty air filter.
5. Low oil lavel/dkty oil.
6. Faulty spark plug.
7. Dirty fuel tilter.
8. Stale or dirty fuel.
9. Water in fuel.
10. Spark plug wire loose,
11. Dirty engine air screen/fins.
12. Dirty/clogged muffler.
13. Loose or damaged widng.
14 Carburetor out of adjustment.
15. Engine valves out ot adjustment.
1. Wom, bent orloose blade.
2. Bent blade mandrel
3, Loose/damaged part(s).
CORREC_ON
1. Fill fuel tank.
2. See "TO START ENGINE" in Operation secfion.
3. Wait several minutes before attempting to start.
4. Replace spark plug.
5. Clean/replace air tilter.
6. Replace fuel filter.
7. Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel filter.
8. Check all wiring.
9. See "To Adjust Carburetor" inService Adjustments
section.
10. Contact an authorized service canter/department.
t. Clean/replace air tilter.
2. Replace spark plug.
3. Recharge or replace battery.
4. Replace fuel tilter.
5. Drain fuel tank and refill with fresh gasoline.
6. Check all wiring.
7. See "To Adjust Carburetor" in Service Adjustments
section.
8. Contact an authorized service center/department.
1. Depress dutch/brake pedal.
2. Disengage attachment clutch.
3. Recharge or replace battery.
4. Replace fuse.
5. Clean battery terminals.
6. Check all wiring.
7. Check]raplace ignition switch.
8. Check]replace solenoid or starter.
9. Contact an authorized service center/department.
1. Recharge or replace battery.
2. Clean battery terminals.
3. Check all wiring.
4. Check]replace solenoid or starter.
1. Set in "Higher Cut" positioniredu,:e speed,
2. Adjust thro_e control.
3. Clean underside of mower housing.
4. Clean/replace air filter.
5. Check oil level/change oil.
6, Clean and regap or change spark plug.
7. Replace fuel filter,
8. Drain fuel tank and refill with fresh gasoline.
9. Drain fuel tank and carburetor, refill tank with fresh
gasoline and replace fuel tilter.
10, Connect and tighten spark plug wire.
11. Clean engine air screen/fins.
12. Clean/replace muffler.
13. Check all wiring,
t4. See "To Adjust Carburetor" in Service Adjustments
section.
15. Contact an authorized service center!department.
1. Replace blade. Tighten blade bolt.
2. Replace blade mandrel.
3. T_ghten loose part(s). Replace damaged parts.
26
Loading ...
Loading ...
Loading ...