Loading ...
Loading ...
Loading ...
I I I I I I 1
TROUBLESHOOTING POINTS
I I
CAUSE CORRECTION
PROBLEM
Willnotstart
Hardto start
Engine will notturn over
Engine clicks but will not
start
Loss of power
Excessive vibration
1. Out of fuel.
2. Engine not "CHOKED" properly.
3. Engine flooded.
4. Bad spark plug.
5. Dirty air tilter.
6. Dirty fuel tilter,
7. Water in fuel.
8. Looseordamagedwiring.
9. CarburetoroutofadjustrnenL
10. Enginevalvesoutofadjustment.
1. Dirty air filter,
2. Bad spark plug.
3. Weak or dead battery.
4. Dirty fuel filter.
5. Stale or dirty fuel.
6. Loose or damaged widng.
7. Carburetor out of adjustment
8. Engine valves out of adjustment.
1. Clutch/brakepedalnotdepressed.
2. Attachmentdutch isengaged.
3. Weak ordeadbattery.
4. Blownfuse.
5. Corrodedbatteryterminals.
6. Loose ordamagedwidng.
7. Faultyignitionswitch.
8. Faultysolenoidorstarter.
9. Faultyoperatorpresenceswitch(as).
1, Weak or dead battery.
2. Corroded battery terminals,
3. Loose or damaged widng.
4. Faulty solenoid or starter.
1. Cutting too much grass/too fast.
2. ThrottJein =CHOKE. position.
3. Build-up of grass, leaves and trash under mower.
4. Dirty air filter.
5. Low oil level/dirty oil,
6. Faulty spark plug.
7. Dirty fuel tilter.
8. Stale or dirty fuel.
9. Water in fuel.
10. Spark plug wire loose.
11. Dirty engine air scrasnifins.
12, Didy/clngged muffler.
13. Loose or damaged wiring.
14. Carburetor out of adjustmanL
15. Engine valves out of adjustment.
1. Worn.bentorlooseblade.
2. Bentblademandrel.
3. Loose/damagadpart(s).
1. Fillfuel tank.
2. See =TOSTARTENGINE"inOperationsection.
3. Waitseveralminutesbeforeattemptingtostart.
4. Replacesparkplug.
5. Clean/replaceairfilter.
6. Replacefuel filter.
7. Drainfuel tankand carburetor,refilltankwith fresh
gasolineandreplacefuelfilter.
8. Checkallwiring.
9. See =ToAdjustCarburetor"in ServiceAdjustments
section.
10. Contactan authorized servicecanter/departmant.
1. Clean/repleceairfilter.
2. Replacesparkplug.
3. Rechargeorreplacebattery.
4. Replacefuel filter.
5. Drainfueltank andrefillwithfreshgasoline.
6. Checkallwiring.
7. See =ToAdjustCarburetor";nServiceAdjustments
section.
8. Contactan authorizedservicecanter/departmant.
1. Depress cfutchrorake pedal.
2. Disengage attachment clutch.
3. Recharge or replace battery.
4. Replace fuss.
5. Clean battery terminals.
6. Check all wiring.
7, Check/replace ignition switch.
8. Check/replace solenoid or starter.
9. Contact an authorized service center/department.
1. Rechargeor replacebattery.
2. Cleanbatteryterminals.
3. Checkall widng.
4. Check/replacesolenoidorstarter.
1. Set in =Higher Cut" position/reduce speed,
2. Adjust throttle control.
3. Clean underside of mower housing.
4. Clean/replace air filter.
5, Check oil level/changa oil.
6. Clean and rsgap or change spark plug.
7. Replace fuel filter.
8. Drain fuel tank and refillwith fresh gasoline.
9. Drain fuel tank and carbure_r, refilltank with fresh
gasoline and replace fuel filter.
10. Connect and tighten spark plug wire.
11, Clean engine air screen/fins.
12. Clean/replace muffler.
13. Check all wiring.
t 4. See =To Adjust Carburetor" in Service Adjustments
section.
15. Contact an authorized service center/department.
1. Replace blade. Tighten blade bolt.
2. Replace blade mandrel.
3. Tighten loose part(s). Replace damaged pads.
24
Loading ...
Loading ...
Loading ...