Loading ...
Loading ...
Loading ...
STORAG
Immediately prepare your tractor for storage at the end of
the season or if the unit will not be used for 30 days Or mere.
TRACTOR
Remove mower from tractor for winter storage. When
mower is to be stored for a period of time, clean it thor-
oughly, remove atl dirt, grease, leaves, etc. Store in a
clean, dry area.
" Clean entire tractor (See"CLEANING" inthe Customer
Responsibilities section of this manual).
- Inspect and replace belts, if necessary (See belt re-
placement instructions in the Service and Adjustments
section of this manual).
* Lubricate as shown in the Customer Responsibilities
section of this manual.
Be sure that all nuts, bolts and screws are securely
fastened. Inspect moving parts for damage, breakage
and wear. Replace if necessary.
, Touch up all rusted or chipped paint surfaces; sand
lightly before painting.
BATTERY
Fully charge the battery for storage.
After a period of time in storage, battery may require
recharging.
To help prevent corrosion and power leakage during
long periods of storage, battery cables should be
disconnected and batterycleaned thoroughly (see"TO
CLEAN BATTERY AND TERMINALS in the Cus-
tomer Responsibilities section of:this manual).
• After cleaning, leave cabbs disconnected and place
cables where they cannot come in contact with battery
terminals.
• Be sure battery drain tube is securely attached.
ENGINE
FUEL SYSTEM
iMPORTANT: IT tS IMPORTANT TO PREVENT GUM
DEPOSITS FROM FORMING IN ESSENTIAL FUEL
SYSTEM PARTS SUCH AS CARBURETOR, FUEL FILTER,
FUEL HOSE, OR TANK DURtNG STORAGE. ALSO,
EXPERIENCE INDICATES THAT ALCOHOL BLENDED
FUELS (CALLED GASOHOL OR USING ETHANOL OR
METHANOL) CAN ATTRACT MOISTURE WHICH LEADS
TO SEPARATION AND FORMATION OF ACIDS DURING
STORAGE. ACIDtC GAS CAN DAMAGE THE FUEL
SYSTEM OF AN ENGINE WHILE IN STORAGE.
,, Drain the fuel tank,
Start the engine and let it run until the fuet lines and
carburetor are empty.
Never use engine or carburetor cleaner products in the
fuel tank or permanent damage may occur.
o Use fresh fuel next season.
NOTE; Fuel stabilizer is an acceptable alternative in
minimizing the formation of fuel gum deposits during stor u
age. Add stabilizer to gasofine in fuel tank or storage
container+ Always follow the mix ratio found on stabilizer
container. Run engine at least t0 minutes after adding
stabilizer to allow the stabilizer to reach the carburetor. Do
not drain the gas tank and carburetor if using fuei stabilize r.
ENGMNE O|L
Drain oil (with engine warm) and replace with ctean engine
oiI. (See "ENGINE" in the Customer Responsibilities
section of this manual).
CYLINDERS
Remove spark plug(s).
Pour one ounce of oil through spark plug hob(s) into
cylinder(s).
o Turn ignition key to"START' position for a few seconds
to distribute oil.
o Replace with new spark plug(s).
OTHER
Do not store gasoline from one season to another.
, Replace your gasoline can if your can starts to rust.
Rust and/or dirt in your gasoline will cause problems.
If possible, store your unit indoors and cover it to give
protection from dust and dirt.
Cover your unit with a suitable protective cover that
does not retain moisture. Do not use plastic° Plastic
cannot breathe which at!ows condensation to form and
will cause your unit to rust.
iMPORTANT: NEVER COVER TRACTOR WHILE ENGINE
AND EXHAUST AREAS ARE STILL WARM.
25
Loading ...
Loading ...
Loading ...