Loading ...
Loading ...
Loading ...
In addition, there are several exceptions to the Normal Schedule. They
are listed below:
COOLANT CHANGE RECORD
Normal Vehicle Axle Maintenance
❑
Rear axles and power take-off (PTO) units containing synthetic lubricant and light duty trucks equipped with Ford-design
axles are lubricated for life. These lubricants are not to be checked or changed unless a leak is suspected, service is re-
quired or the axle assembly has been submerged in water. The axle and PTO lubricant should be changed anytime the axle
and PTO have been submerged in water. During extended trailer tow operation above 70°F ambient and wide open throttle
for extended periods above 45 mph, non-synthetic rear axle lubricants should be replaced every 3,000 miles or 3 months,
whichever occurs first. The 3,000 mile lube change interval may be waived if the axle was filled with 75W140 synthetic
gear lubricant meeting Ford specification WSL-M2C192-A, part number F1TZ-19580-B or equivalent. Add friction modifier
C8AZ-19B546-A (EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear axles (see
Owner’s Guide
for quantity).
The axle lubricant should be changed anytime an axle has been submerged in water.
Police/Taxi/Livery Vehicle Axle Maintenance
❑
Replace rear axle lubricant every 100,000 miles. Rear axle lubricant change may be waived if the axle was filled with
75W140 synthetic gear lubricant meeting Ford specification WSL-M2C192-A, part number FITZ-19580-B or equivalent. Add
four ounces of additive friction modifier C8AZ-19B546-A (EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear
axles. The axle lubricant should be changed anytime the axle has been submerged in water.
E–450 and F–450/550 Axle Maintenance
❑
Replace rear axle lubricant every 100,000 miles under normal driving conditions on all E–450 and F–450/550 applica-
tions. For E–450 and F–450/550 vehicles operated at or near maximum Gross Vehicle Weights, the rear axle lubricant
should be replaced every 50,000 miles. In addition, this 50,000 mile schedule should be observed when the vehicles are
operated under the Special Operating Conditions, where noted, on page 148.
California Fuel Filter Replacement
❑
If vehicle is registered in California, the California Air Resources Board has determined that the failure to perform this main-
tenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle’s useful life.
Ford Motor Company, however, urges you to have all recommended maintenance services performed at the specified inter-
vals and to record all vehicle service.
Class A Motorhome
❑
Every two years - Change brake fluid
Engine coolant
❑
6 years or 105,000 miles (168,000 km) - change coolant (whichever comes first).
❑
After initial change - change coolant every 3 years or 45,000 miles (72,000 km).
Scheduled Maintenance Guide
152
2011 Motorhome (mot)
Supplement, 1st Printing
USA (fus)
Loading ...
Loading ...
Loading ...